7 recalls found. |
DEFECT #1 - TIRES:TREAD/BELT
Posted on: 2001-05-22
Description
This is not a safety recall in accordance with the safety act. However, it is deemed a safety improvement campaign by the agency. Equipment description: ford is replacing all firestone wilderness at 15, 16, and 17 inch tires mounted on ford trucks and suvs. Ford reports tread separation can occur due to a combination of the sensitivity of the tire design to stress, aging, and manufacturing differences between plants. Ford is replacing these tires to prevent possible premature tire failure. Vehicle description: the vehicles listed below may have been originally equipped with firestone wilderness at tires or may have had wilderness at tires installed during the firestone recall launched in august 2000. Certain 1991 throught 2002 ford explorer certain 2001 throught 2002 explorer sport, and sport trac certain 1997 through 2002 mercury mountaineer certain 1991 through 2001 ranger certain 1999 through 2001 expedition certain 1991 through 1994, and 1997 model year f-series certain 1991 through 1994 bronco note: both original equipment and replacement tires are affected.
Consequence
Should the tread separate at highway speeds, a vehicle crash could occur, possibly resulting in personal injury or death.
Corrective Action
The replacement/reimbursement program for this campaign expired on march 31, 2002. However, customers can contact ford at 1-877-917-3673 or go on-line to www.ford.com for possible assistance.
Notes
DEFECT #2 - PARKING BRAKE:CONVENTIONAL
Posted on: 1994-11-23
Description
The parking brake control self-adjust pawl does not line up properly with the self-adjust rachet causing the pawl to slip over one or more teeth in the rachet.
Consequence
When the above occurs, it can result in parking brake system ineffectiveness. The parking brake will not hold the vehicle, causing the vehicle to roll freely, if the transmission is not left in gear.
Corrective Action
A wedge will be installed which will serve to lock the parking brake self-adjust mechanism pawl into engagement with the rachet. Also, owners will be advised to release and reapply the parking brake whenever tooth skip occurs and will be reminded to always turn off the engine and leave the vehicle in gear when the vehicle is parked.
Notes
System: emergency parking brake; mechanical.vehicle description: light duty pickup trucks and multipurpose vehicles with manual transmissions.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonabletime or the remedy does not correct the defect, please contact ford at 1-800-392-3673. Also, contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #3 - POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
Posted on: 1993-05-27
Description
The transfer cases have been built with the wrong electric shift motor. The transfer cases can slip out of the 4 x 4 high gear position during coasting in forward gears or with power applied in reverse gear.
Consequence
If this occurs, the vehicle can roll freely as if inneutral position regardless of the transmission gear selector position. This canresult in loss of vehicle control and an accident.
Corrective Action
Replace defective transfer cases with the correct version.
Notes
System: power train; transfer case.vehicle description: 4wd light trucks and multi-purpose passenger vehicleswith touch drive electric shift transfer cases.
DEFECT #4 - STRUCTURE:BODY:BUMPERS
Posted on: 1994-02-04
Description
The u-clip style nuts that retain the front bumpers to the front bumper inner arms can fracture.
Consequence
If one of the u-clip nuts fractures, the bumper will loosen and rattle causing fracture of the remaining u-clip nuts, resulting in separation of the bumper from the vehicle. If the bumper were to detach from the vehicle while it is being driven, a vehicle collision could result.
Corrective Action
Inspection and replacement of the four u-clip nuts and the associated bolts.
Notes
System: structure; bumper assembly. Vehicle description: light duty pickup trucks and multipurpose vehicles.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided within a reasonable time and free of charge or the remedy does not correct the defect or noncompliance, please contact ford service center at 1-800-392-3673.also, contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #5 - EXTERIOR LIGHTING
Posted on: 2006-03-23
Description
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Corrective Action
Pro-a motors will notify owners and offer to repurchase the lamps. The recall began on april 3, 2006. Owners may contact pro-a motors at 323-838-2988.
Notes
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled lamp model numbers.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #6 - VEHICLE SPEED CONTROL:CRUISE CONTROL
Posted on: 2008-02-04
Description
Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. The affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.
Consequence
As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.
Corrective Action
Dealers will install a new wiring harness, or replace the mating electrical component. The recall began on february 18, 2008. Owners may contact ford at 1-800-392-3673.
Notes
Ford recall no. 08s01.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #7 - VEHICLE SPEED CONTROL
Posted on: 2007-08-03
Description
On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
Consequence
This could result in an underhood fire.
Corrective Action
Dealers will install a fused wiring harness. Owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. As soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. The recall began on august 13, 2007, and mailing completed by september 19, 2007. Owners may contact ford at 1-888-222-2751.
Notes
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration;s vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.