5 recalls found. |
DEFECT #1 - TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
Posted on: 2000-02-02
Description
Vehicle description: heavy duty class 8 trucks equipped with fontaine fifth wheel assemblies, models sl5wms6125, sl5wms7125, sl5wms8125, sl5wms9125, sl5wms10125, sl5apm6125, sl5apm7125, slapm8125, sl5apm9125, sl5apm10125, sl5wms-d, sl5apm-d, and sl5bps-d. Improper installation of the fifth wheel assembly can cause cracking of the fifth wheel mounting plate.
Consequence
Under the trailer loading, the mounting plate could eventually fail due to fatigue.
Corrective Action
Dealers will inspect and replace the mounting plates that are cracked.
Notes
Volvo truck recall no. Rvxx0001.owner notification began march 8, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1-800-528-6586 or fontaine at 1-800-874-9780.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION:LINES AND FITTINGS
Posted on: 1998-10-15
Description
Vehicle description: class 8 heavy duty trucks. The air suspension control valve supply line was not plumbed through an air pressure protection valve. In the event of a failure, there would be loss of air pressure in the 'b' system air reservoir that supplies air pressure for the front steer axle brakes.
Consequence
This condition would result in increased stopping distances.
Corrective Action
Dealers will install the necessary air pressure protection valve.
Notes
Owner notification began during november 1998. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1-800-528-6586.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Posted on: 1997-09-22
Description
Vehicle description: heavy duty trucks. The steel braided tether of the safety belt buckle is deformed and can possibly be cracked. This happens as the seats are being moved on the sliding rail, at the same time they are often caught and pinched under the seat frames.
Consequence
In the event of a vehicle crash, the seat occupant may not be properly restrained increasing the risk of personal injury.
Corrective Action
Dealers will inspect and replace seat belt buckles with the cable tether.
Notes
Owner notification is expected to begin by november 1, 1997.owners who take their vehicles to an authorized dealer on an agreed
DEFECT #4 - SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 1995-09-27
Description
Air system blockage in the air dryer occurs degrading the moisture removing capabilities of the dryer when the vehicle is operated in a cold environment and moisture accumulates and freezes in the air dryer or in the line between the dryer and the air system reservoir. The air dryer can become overpressurized causing the air dryer cartridge to separate from the mounting base.
Consequence
If the air dryer separates from the base, the cartridgecan separate sufficiently enough to cause personal injury or property damage.
Corrective Action
Dealers will equip air systems with a pressure relief valve to be located between the compressor and the air dryer. This pressure relief valve is intended to vent if excessive pressure develops in the air dryer.
Notes
System: brakes; air dryer.vehicle description: heavy duty class 8 trucks equipped with rockwell wabco system saver 1000 air dryer.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, contact volvo gm heavy truck corporation at 1-910-279-2000.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #5 - SEAT BELTS:FRONT:ANCHORAGE
Posted on: 1993-05-27
Description
The safety belt buckle assembly can get caught in the seat suspension mechanism. The movement of the air suspension seat could cause the safety belt buckle tether cable to fray .
Consequence
Fraying of the safety belt buckle tether cable couldresult in failure of the cable and increased risk of injury to seat occupantin an accident.
Corrective Action
Replace the safety belt buckle assembly with a new design buckle assembly.
Notes
System: interior; safety belts.vehicle description: class 7 and class 8 heavy duty trucks equipped with airsuspension seats.