4 recalls found. |
DEFECT #1 - SEAT BELTS:FRONT:ANCHORAGE
Posted on: 1999-05-20
Description
Vehicle description: fire trucks. These fire trucks are all 4-door models which contain dual, forward facing passenger seats. The hardware utilized to mount the seat box to the cab floor and to the backwall structure, and also to mount the type 1 seat belt systems, was inadequate to meet the requirements of fmvss nos. 207/210, seating systems and seat belt assembly anchorages.
Consequence
The seat box mounting/restraining hardware can loosen or fail allowing the seat/seat box assembly to break free of its mounting to the cab floor and/or backwall which could cause injury to the occupants of those seats.
Corrective Action
Dealers will replace the seat box mounting fasteners.
Notes
Owner notification began november 29, 1999. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact spartan at 1-800-722-3025.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - SUSPENSION
Posted on: 1998-11-10
Description
Vehicle description: fire trucks. If the driver accelerates in a turn above 20 mph forward speed, the lock pin is actuated and causes the axle to resist returning to the straight ahead position after the turn is completed because the lock pin is binding on the clamp plate surface.
Consequence
Engaging the lock pin in the lcmp plate hole at high forward speeds causes excessive wear in the lock pin and/or the clamp plate hole. Lane changes and other vehicle maneuvers will greatly increase contact frequency and causes wear, increasing the risk of loss of vehicle control.
Corrective Action
Dealers will replace the tag axles on these fire trucks.
Notes
Owner notification began august 16, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact spartan at 1-800-722-3025.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - STRUCTURE
Posted on: 1999-01-27
Description
Vehicle description: fire trucks. The cab tilt system contains a 12 volt electrical solenoid assembly as an accessory to the cab tilt electric motor/hydraulic pump assembly. Rain, snow, salt spray or other corrosive environment can corrode the solenoid or bridge the energizing coil wire terminal causing the cab tilt system to operate uncontrollably.
Consequence
This could cause the cab tilt system to actuate without control, increasing the risk of personal injury.
Corrective Action
Dealers will install a hermetically sealed solenoid assembly.
Notes
Owner notification began june 18, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact spartan at 1-800-722-3025. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 1995-09-28
Description
Air system blockage in the air dryer occurs degrading the moisture removing capabilities of the dryer when the vehicle is operated in a cold environment and moisture accumulates and freezes in the air dryer or in the line between the dryer and the air system reservoir. The air dryer can become overpressurized causing the air dryer cartridge to separate from the mounting base.
Consequence
If the air dryer separates from the base, the cartridge can separate sufficiently enough to cause personal injury or property damage.
Corrective Action
Dealers will equip air systems with a pressure relief valve to be located between the compressor and the air dryer. This pressure relief valve is intended to vent if excessive pressure develops in the air dryer.
Notes
System: brakes; air dryer.vehicle descritpion: fire trucks equipped with rockwell wabco system saver1000 air dryer.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, contact spartan at 1-800-543-5008. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.