12 recalls found. |
DEFECT #1 - VISIBILITY:WINDSHIELD WIPER/WASHER
Posted on: 1999-02-11
Description
Vehicle description: light duty pickup trucks and sport utility vehicles, 2 and 4-wheel drive. Solder joints near the wiring harness connector can crack causing the windshield wipers to work intermittently.
Consequence
This condition can result in inoperative wipers, reducing a driver's visibility, and increasing the risk of a vehicle crash.
Corrective Action
Dealers will replace the wiper motor circuit board and cover.
Notes
Owner notification began december 15, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - SEATS
Posted on: 1997-03-24
Description
Vehicle description: extended cab and 2-door utility vehicles equipped with reclining seats and the easy-entry feature. These vehicles exhibit a condition in which a pinch point exists in the recliner mechanism that can trap and pinch a person's hand or finger(s) when the easy-entry feature is activated.
Consequence
This pinching can cut the hand or possibly sever the finger(s) without prior warning.
Corrective Action
Dealers will install a protector cover over the recliner mechanism.
Notes
Owner notification:owner notification is expected to begin during march 1997. Note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #3 - FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Posted on: 1998-08-17
Description
Vehicle description: crew cab pickup trucks. The front, inner corner of the fuel tank can contact the body sill either intermittently or constantly. This movement can cause a discernible noise and, over time, can wear a hole in or crack the fuel tank at point of contact.
Consequence
This condition can result in fuel leakage and a distinct fuel odor if the tank were filled above the level of the hole or crack. In the presence of an ignition source, a fire could result.
Corrective Action
Dealers will inspect the fuel tank for wear and, either install a spacer between the fuel tank and the front crossmember, or if necessary, replace the fuel tank.
Notes
Owner notification began august 24, 1998. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - VEHICLE SPEED CONTROL
Posted on: 1996-04-17
Description
These vehicles were assembled with the throttle cable contacting the dash mat which could bind the throttle. This does not meet with the maximum return times required by federal motor vehicle safety standard no. 124, accelerator control systems.
Consequence
Consequence of non-compliance: the engine speed may not return to idle increasing the potential for a vehicle accident.
Corrective Action
Dealers will inspect for adequate throttle cable to dash mat clearance, and if there is insufficient clearance, cut out a portion of the dash mat to provide proper clearance.
Notes
System: fuel; throttle linkages and control; fmvss no. 124. Vehicle description: pickup trucks, cab/chassis, utility and multi-purpose trucks equipped with gasoline engines. Note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #5 - SEAT BELTS:FRONT
Posted on: 1996-01-02
Description
If both the lap-belt and shoulder-belt energy management loops on the front seat belt assemblies release at or near the same time, acceleration forces can cause the buckle release mechanism to activate and allow the buckle to separate from the latch.
Consequence
If the buckle released, the system would fail to provide adequate occupant restraint protection.
Corrective Action
Dealers will remove the stitching that creates the energy management loop in the shoulder belt(s).
Notes
System: interior; seat belts; front.vehicle description: light duty pickup trucks, extended cab, equipped withgas engines or 6.5l h.o. Turbo diesel engines.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #6 - SEAT BELTS:FRONT
Posted on: 1996-01-02
Description
These vehicles were built with front seat belt systems with no energy management loops and may not meet the head injury criteria requirements of fmvss no. 208, occupant crash protection.
Consequence
In the event of a vehicle crash, the occupants of these seats may not be properly restrained.
Corrective Action
Dealers will replace the retractor portion of the seat belt assembly(s) with one having the newly designed energy-management twin-loop system.
Notes
System: interior; seat belts; front, fmvss no. 208.vehicle description: light duty pickup trucks, with extended cabs, and equipped with 6.5l naturally aspirated diesel engines and 6.5l turbo diesel engines.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #7 - STEERING:WHEEL AND HANDLE BAR
Posted on: 1996-01-22
Description
The steering column upper intermediate-shaft nut may not be torqued to proper specifications. The nut could loosen and detach allowing the through-bolt that secures the upper intermediate-shaft to the lower steering column shaft joint to fall out.
Consequence
This loose engagement can provide noticeable noise and abnormal steering feeling to the driver and, if left unattended, the steering shafts can separate resulting in a loss of steering control.
Corrective Action
Dealers will torque the suspect fasteners to the proper specifications.
Notes
System: steering; column shaft upper. Vehicle description: light duty pickup trucks.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #8 - SEATS
Posted on: 1996-03-29
Description
The seat recliner to seat frame attaching bolts on these vehicles could loosen, fatigue and fracture, allowing the seat back to suddenly recline.
Consequence
If this were to occur to the driver's seat, this could result in a sudden loss of vehicle control increasing the risk of a vehicle accident.
Corrective Action
Dealers will remove all foam and/or fabric sandwiched between the recliner assembly and the seat frame, install washers between the seat recliner and the seat frame at each attachment point, and install new attaching bolts torqued to a higher specification. These corrections will be made to both the driver's and passenger's seats.
Notes
System: interior; seat track anchors and seat.equipment description: front high-back bucket seats or 60/40 split bench seats provided by vehicle safety systems for installation in light duty pickup extended cab conversion trucks.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact vss at 1-800-742-5043. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #9 - EXTERIOR LIGHTING
Posted on: 2006-06-29
Description
Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash
Corrective Action
Aai motorsports will notify owners and replace the lamps free of charge. The recall began on august 1, 2006. Owners may contact aai motorsports at 909-923-9188.
Notes
This recall only pertains to aai motorsports aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled lamp model numbers.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #10 - EXTERIOR LIGHTING:HEADLIGHTS
Posted on: 2008-08-14
Description
K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. These headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.
Corrective Action
K2 motor will notify owners and offer a full refund. The recall began on decemeber 17, 2008. Owners may contact k2 motor at 1-909-839-2992.
Notes
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by honda, ford, or chrysler llc. Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #11 - EXTERIOR LIGHTING
Posted on: 2009-04-07
Description
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. These lamps do not contain the required amber side reflectors.
Consequence
Decreased lighting visibility may result in a vehicle crash.
Corrective Action
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.
Notes
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under document search located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #12 - EXTERIOR LIGHTING:HEADLIGHTS
Posted on: 2009-05-11
Description
Dope, inc. Is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. These lamps do not contain the required amber side reflectors.
Consequence
Decreased lighting visibility may result in a vehicle crash.
Corrective Action
Dope, inc. Will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on july 28, 2009. Owners may contact dope, inc. At 1-626-272-1798.
Notes
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under document search located at the bottom of your screen. Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .