16 recalls found. |
DEFECT #1 - AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE
Posted on: 2001-10-10
Description
Equipment description: passenger vehicles that have had the driver's air bag module replaced after april 5, 2000. The replacement driver's air bag module inflator may have insufficient welds that could prevent proper inflation of the air bag.
Consequence
In the event of a crash, the driver's air bag may not properly deploy which could potentially result in less than the intended level of occupant protection.
Corrective Action
Dealers will inspect and, if necessary, replace the driver's air bag module. Owner notification began october 5, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
Posted on: 2002-01-02
Description
Vehicle description: taurus/sable vehicles equipped with 3.0l and 3.8l engines and mustang vehicles with 3.8l and 5.0l engines. It is possible for the engine cooling fan bearing to seize.
Consequence
Should this occur, excessive heat could be generated which could melt the fan motor electrical connector. Components inside the cooling fan motor could ignite potentially resulting in an underhood fire.
Corrective Action
Dealers will inspect the engine cooling fan assembly and install a circuit breaker. If the cooling fan is inoperative, the fan and motor assembly will be replaced. Owner notification began december 28, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
Posted on: 2002-01-07
Description
This is not a safety recall in accordance with the safety act. However, it is deemed a safety improvement campaign by the agency. Vehicle description: 1995 taurus/sable passenger vehicles equipped with 3.0l and 3.8l engines and 1995 ford mustang vehicles with 3.8l and 5.0l engines. It is possible for the engine cooling fan bearing to seize.
Consequence
Should this occur, excessive heat could be generated which could melt the fan motor electrical connector. Components inside the cooling fan motor could ignite potentially resulting in an underhood fire.
Corrective Action
Dealers will replace the engine cooling fan motor assembly at no charge to consumers. Ford is extending the limited warranty on the engine cooling fan motor to a total of 8 years or 100,000 miles from the warranty start date, whichever occurs first. This coverage is automatically transferred to subsequent owners at no charge. If the vehicle already has more than 100,000 miles, this coverage will last until june 30, 2002. If the consumer has paid to have this service done before december 2001, ford is offering a refund. Owners can contact ford at 1-866-436-7332, concerning this program.
Notes
Ford has decided to conduct a service campaign to replace the engine cooling fan motor assembly. Owners can contact ford at1-866-436-7332, concerning this program.
DEFECT #4 - PARKING BRAKE:CONVENTIONAL
Posted on: 2000-10-31
Description
Vehicle description: passenger vehicles equipped with manual transmissions. If a vehicle is parked with the parking brake not fully applied and not in first gear, as directed in the owner guide, and the self adjustment pawl subsequently skips one or two teeth, the vehicle could move on some grades.
Consequence
This could result in unintended vehicle movement and a vehicle crash without prior warning.
Corrective Action
Dealers will modify the parking brake control and install a plate or over-bracket to the control to lock the self adjust mechanism in position following adjustment.
Notes
Owner notification began november 28, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #5 - STRUCTURE:BODY:HOOD
Posted on: 1997-10-21
Description
Vehicle description: passenger vehicles and mini vans. Tearing of the bond between the inner and outer hood panels during minor front end collisions can result in a gap at the leading edge of the hood. Air forced between the inner and outer panels can produce enough pressure to force the outer panel upward.
Consequence
This condition can result in total separation of the outer hood panel.
Corrective Action
Dealers will inspect the hood area for any damage along the leading edge of the hood. If there is any evidence of bond separation, the hood will be replaced. If there is no evidence of bond separation, additional adhesive will be applied between the inner and outer hood panels.
Notes
Owner notification began november 10, 1997. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #6 - STEERING:LINKAGES:TIE ROD ASSEMBLY
Posted on: 1995-07-21
Description
The affected vehicles were built with outer tie rod ends with incorrect taper ball studs. The incorrect tapered ball studs can fracture within 50,000 miles.
Consequence
A fractured ball stud can result in a noticeable shake or shimmy and could cause the affected wheel to tuck inward or outward, increasing the potential for a vehicle accident.
Corrective Action
Dealers will inspect the outer tie rod ends and replace the incorrectly tapered ball studs.
Notes
System: steering; linkages; tie rod; end.vehicle description: passenger vehicles.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact ford at 1-800-392-3673. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #7 - AIR BAGS:FRONTAL
Posted on: 1995-02-28
Description
The passenger side air bag has an inflator body that cracked during forming of the curl that retains the igniter plug in the end of the inflator. Also the igniter end cap can separate from the inflator.
Consequence
The passenger side air bag may not inflate properly resulting in reduced occupant protection in a vehicle accident. If the igniter end cap separates in a frontal collision, hot gases can be released and ignite flammable material or cause burn injuries.
Corrective Action
Dealers will remove and replace the passenger side air bag module.
Notes
System: interior; passive restraints; air bag; passenger. Vehicle description: passenger side air bag in passenger cars, vans andmulti-purpose vehicles. Note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, contact ford at 1-800-392-3673. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #8 - EXTERIOR LIGHTING
Posted on: 2006-07-17
Description
Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
Corrective Action
Tradesonic will notify owners and replace the lamps free of charge. The recall is expected to begin during july 2006. Owners may contact tradesonic at 626-934-8884.
Notes
This recall only pertains to tradesonic aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled lamp model numbers.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #9 - EXTERIOR LIGHTING
Posted on: 2006-06-29
Description
Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash
Corrective Action
Aai motorsports will notify owners and replace the lamps free of charge. The recall began on august 1, 2006. Owners may contact aai motorsports at 909-923-9188.
Notes
This recall only pertains to aai motorsports aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled lamp model numbers.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #10 - EXTERIOR LIGHTING
Posted on: 2006-06-05
Description
Certain ck motorsports combination headlights, clear corner, bumper, and side marker lights sold as replacement lamps for use on the passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Corrective Action
Ck motorsport will notify owners and replace the noncompliant lamps free of charge. The recall began on july 1, 2006. Owners may contact ck motorsport at 1-909-610-7211.
Notes
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.for more information on the lamp model numbers, click on document search and view document titled lamp model numbers.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #11 - EXTERIOR LIGHTING:HEADLIGHTS
Posted on: 2006-03-21
Description
Certain poli-auto combination headlamp assemblies, p/nos. 11-728, 11-728d, 11-710, 11-419, 11-713, 11-703, 11-704, 11-708p, 11-735, 11-725, 11-726, 11-716 (p&c), 11-721-1, 11-733, 11-729, 11-730, and 11-732, sold as replacement lamps for use on certain passenger vehicles. Some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Corrective Action
Poli-auto will notify owners and offer to repurchase the headlamps at its original purchase price. The recall is expected to begin during april 2006. Owners may contact poli-auto at 305-477-1356.
Notes
Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #12 - EXTERIOR LIGHTING
Posted on: 2006-03-23
Description
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Corrective Action
Pro-a motors will notify owners and offer to repurchase the lamps. The recall began on april 3, 2006. Owners may contact pro-a motors at 323-838-2988.
Notes
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled lamp model numbers.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #13 - EXTERIOR LIGHTING:HEADLIGHTS
Posted on: 2006-03-14
Description
Certain anzo combination headlamp assemblies sold as replacement lamps for use on certain passenger vehicles. Some combination lamps are not equipped with amber side reflectors which fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash.
Corrective Action
Anzo will notify owners and replace the headlamps free of charge. The recall began may 9, 2006. Owners may contact anzo usa at 909-468-3688.
Notes
This recall only pertains to aftermarket headlamp assemblies manufactured by anzo and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #14 - EXTERIOR LIGHTING:HEADLIGHTS
Posted on: 2008-08-14
Description
K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. These headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.
Corrective Action
K2 motor will notify owners and offer a full refund. The recall began on decemeber 17, 2008. Owners may contact k2 motor at 1-909-839-2992.
Notes
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by honda, ford, or chrysler llc. Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #15 - EXTERIOR LIGHTING
Posted on: 2009-04-07
Description
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. These lamps do not contain the required amber side reflectors.
Consequence
Decreased lighting visibility may result in a vehicle crash.
Corrective Action
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.
Notes
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under document search located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #16 - EXTERIOR LIGHTING:HEADLIGHTS
Posted on: 2009-05-11
Description
Dope, inc. Is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. These lamps do not contain the required amber side reflectors.
Consequence
Decreased lighting visibility may result in a vehicle crash.
Corrective Action
Dope, inc. Will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on july 28, 2009. Owners may contact dope, inc. At 1-626-272-1798.
Notes
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under document search located at the bottom of your screen. Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .