7 recalls found. |
DEFECT #1 - VISIBILITY:WINDSHIELD WIPER/WASHER
Posted on: 1999-02-11
Description
Vehicle description: light duty pickup trucks and sport utility vehicles, 2 and 4-wheel drive. Solder joints near the wiring harness connector can crack causing the windshield wipers to work intermittently.
Consequence
This condition can result in inoperative wipers, reducing a driver's visibility, and increasing the risk of a vehicle crash.
Corrective Action
Dealers will replace the wiper motor circuit board and cover.
Notes
Owner notification began december 15, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - VEHICLE SPEED CONTROL
Posted on: 1996-04-17
Description
These vehicles were assembled with the throttle cable contacting the dash mat which could bind the throttle. This does not meet with the maximum return times required by federal motor vehicle safety standard no. 124, accelerator control systems.
Consequence
Consequence of non-compliance: the engine speed may not return to idle increasing the potential for a vehicle accident.
Corrective Action
Dealers will inspect for adequate throttle cable to dash mat clearance, and if there is insufficient clearance, cut out a portion of the dash mat to provide proper clearance.
Notes
System: fuel; throttle linkages and control; fmvss no. 124. Vehicle description: pickup trucks, cab/chassis, utility and multi-purpose trucks equipped with gasoline engines. Note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #3 - POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
Posted on: 1995-02-21
Description
Due to a thin case casting, an external transmission leak can occur.
Consequence
This condition can cause transmission oil to sprayonto the exhaust system and result in a possible vehicle fire.
Corrective Action
Dealers will inspect the transmission case assembly for the involved case casting. If the assembly is involved, the transmission will be replaced.
Notes
System: automatic transmission; cooling unit and lines.vehicle description: pickup trucks and vans equipped with 4l80-e automatic transmission.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, contact chevrolet at 1-800-222-1020 or gmc at 1-810-456-4547. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #4 - POWER TRAIN:AUTOMATIC TRANSMISSION
Posted on: 1995-07-27
Description
The transmission shift-cable lock clip can back out of its installed position resulting in a loss of cable adjustment. When the shift lever is placed in the park position, the park indicator light may not illuminate.
Consequence
The vehicle can move unintentionally if the driver does not notice that the indicator light is not on and does not apply the parking brake.
Corrective Action
Dealers will adjust the shift cable and install a lock clip.
Notes
System: powertrain; automatic transmission.vehicle description: light duty trucks equipped with m30/mt1 automatic transmissions.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time,should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #5 - AIR BAGS
Posted on: 1995-07-27
Description
The vehicles have both the supplemental inflatable restraint (sir) label and an engine start label installed on the same side of the sun visor. This does not comply with fmvss no.208, occupant crash protection.
Consequence
Consequence of non-compliance: operators could fail to notice and heed the warning label.
Corrective Action
The engine start label will be removed from the stowed side of the sun visor and a new engine start label will be installed on the headliner in the sun visor depression. Owners will receive the new label and can install the label themselves or have a dealer install it.
Notes
System: interior; passive restraints; air bag; fmvss no.208.vehicle description: light duty trucks and multi purpose passenger vehicles equipped with l56/l65 diesel engines.note: if you do not receive a new label in a reasonable time free of charge please contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #6 - VISIBILITY:WINDSHIELD WIPER/WASHER
Posted on: 2003-04-30
Description
On certain minivans, pickup trucks, and sport utility vehicles with certain model-engine combinations, the windshield wiper motor may fail due to cracked solder joints on the controller circuit board. The windshield wipers could work intermittently or not at all.
Consequence
If this were to occur during bad weather, driver visibility would be reduced, which could result in a crash.
Corrective Action
Dealers will replace the wiper motor circuit board and cover. Owner notification began on june 19, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, gmc at 1-800-462-8782, or oldsmobile at 1-800-442-6537.
Notes
Gm recall no. 03023.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #7 - FUEL SYSTEM, GASOLINE
Posted on: 2006-05-22
Description
Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on document search and then bus applications). The connector on the fuel filter was not manufactured to honeywell's specification. As a result, the o-ring may not seat correctly on the fuel line.
Consequence
This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. In the presence of an ignition source, a fire could occur.
Corrective Action
Honeywell will notify owners and replace the fuel filters free of charge. The recall began on october 18, 2006. Owners may contact fram customer service at 1-800-890-2075 (option 1).
Notes
This recall only pertains to aftermarket fram fuel filters and has no relation to any original equipment installed on the vehicles listed.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.