5 recalls found. |
DEFECT #1 - SUSPENSION
Posted on: 1996-10-22
Description
The equalizing beam shaft of the tandem axle suspension were manufactured from as-rolled sae4140 steel rather than the specified annealed sae4140. These shafts can fracture inside the beam at the toe of the weld.
Consequence
Vehicles are subject to vehicle tilt and possible rollover in the event that both equalizing beams, on the same side of the vehicle, experience a simultaneous shaft failure. Affected suspensions can also drop and contact the road surface generating sparks which could ignite flammable material.
Corrective Action
Owner notification is being conducted by neway anchorlok. Dealers will inspect and replace all suspension suspension beams with suspension beams containing appropriate shafts.
Notes
Owner notification:owner notification is being conducted by neway anchorlok and began july 18, 1996.note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact neway at 1-800-237-8932.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #2 - SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 1995-09-26
Description
Air system blockage in the air dryer occurs degrading the moisture removing capabilities of the dryer when the vehicle is operated in a cold environment and moisture accumulates and freezes in the air dryer or in the line between the dryer and the air system reservoir. The air dryer can become over pressurized causing the air dryer cartridge to separate from the mounting base.
Consequence
If the air dryer separates from the base, the cartridge can separate sufficiently enough to cause personal injury or property damage.
Corrective Action
Dealers will equip air systems with a pressure relief valve to be located between the compressor and the air dryer. This pressure relief valve is intended to vent if excessive pressure develops in the air dryer.
Notes
System: brakes;air dryer. Vehicle description: heavy duty trucks equipped with rockwell wabco system saver 1000 or system saver twin air dryers.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, contact western star at 1-604-860-3319.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #3 - VEHICLE SPEED CONTROL:SPRINGS
Posted on: 1996-02-06
Description
The throttle return springs can fail.
Consequence
If both springs fail, the engine is not likely to return to idle when the accelerator is released, causing loss of vehicle speed control and suddenly increasing the potential for a vehicle accident.
Corrective Action
Replacement throttle return springs will be mailed directly to owners. If the owners prefer, their dealers can install the springs for them.
Notes
System: fuel; throttle linkages and control return spring.vehicle description: heavy duty trucks and truck/tractors equipped with caterpillar 3306 and 3406 mechanically fuel injected engines.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact western star at 1-604-860-3319. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #4 - ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Posted on: 1996-02-05
Description
These heavy trucks were equipped with exhaust mufflers without heat shielding.
Consequence
Someone working behind the cab could contact the hot muffler causing personal injury. Also some of these vehicles were equipped with deck plates with no grab handles for access.
Corrective Action
Dealers will install muffler shields and, where necessary, grab handles.
Notes
System: exhaust; muffler.vehicle description: trucks and truck/tractors. Note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact western star at 1-604-860-3319. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #5 - EQUIPMENT:RECREATIONAL VEHICLE
Posted on: 1995-02-06
Description
Straps holding the sleeper upper bunk in the raised position can release without warning.
Consequence
If the restraining strap releases suddenly, thebunk falls without warning and can strike an occupant sitting in the lower bunk causing personal injury.
Corrective Action
Dealers will replace the upper bunk retaining straps with an improved automotive safety belt style design strap.
Notes
System: equipment; bunk sleeper.vehicle description: trucks equipped with double sleeper bunks.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, contact western star at 1-604-868-6222. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.