4 recalls found. |
DEFECT #1 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 1996-04-22
Description
The left front brake line can contact the transaxle mounting bracket or attachment bolt.
Consequence
This condition can cause the brake line to wear through, resulting in loss of brake fluid and eventual loss of one-half of the vehicle's brake system, increasing the potential for a vehicle accident.
Corrective Action
Dealers will inspect the vehicle for proper brake line clearance and reposition those brake lines found to have less than minimal clearance. Additionally, those brake lines found to have an indentation caused by the contact will be replaced and properly routed.
Notes
System: brakes; hydraulic; lines.vehicle description: passenger vehicles. Note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact chevrolet at 1-800-222-1020 or buick at 1-800-521-7300. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #2 - FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
Posted on: 1996-07-08
Description
A backfire during engine starting can cause breakage of the upper intake manifold.
Consequence
This condition can cause a no-start condition and possibly an engine compartment fire.
Corrective Action
Dealers will update the powertrain control module programming. Until the campaign repair is made, the vehicle hood should be shut whenever starting the vehicle to reduce the chance of personal injury.
Notes
Vehicle description: passenger vehicles equipped with 3.8l v6 engine. Owner notification: owner notifications began during july 1996. Note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact buick at 1-800-521-7300; pontiac at 1-800-762-2737; or oldsmobile at 1-800-442-6537. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #3 - FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
Posted on: 2007-03-12
Description
Certain delphi fuel pressure regulators, p/nos. Fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. The universal pressure regulators (upr) were produced without an o'ring and retainer.
Consequence
Fuel may leak, possibly resulting in a fire.
Corrective Action
Delphi will notify owners and replace the upr free of charge. The recall began on april 23, 2007. Owners can contact delphi at 877-411-8770.
Notes
This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #4 - STEERING:RACK AND PINION
Posted on: 2003-12-18
Description
Certain passenger vehicles have lower pinion bearings in the power rack and pinion assembly in which the retainer tabs were not crimped properly. These retainers could fail and permit the ball bearings to escape.
Consequence
If this occurs, the pinion shaft can be forced upward during left turns and back down as the steering wheel is moved back and to the right. If the pinion shaft moves further, the driver will need to exert more effort to turn the steering wheel, similar to a vehicle without power assisted steering. If the pinion shaft moves even further, the driver will require much higher effort to turn left and may not be able to turn the wheel as much as intended. With the maximum pinion shaft movement, which requires internal gear component damage, the driver can encounter high resistance to turning left, followed by unintended power assist to the right. In any of these conditions, a crash could occur.
Corrective Action
Dealers will install a new lower pinion bearing unless inspect of the existing bearing indicates that replacement of the gear assembly is necessary. Owner notification began on february 5, 2004. Owners should contact buick at 1-866-608-8080; chevrolet at 1-800-630-2438; oldsmobile at 1-800-630-6537; or pontiac at 1-800-620-7668.
Notes
Gm recall no. 03062.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).