4 recalls found. |
DEFECT #1 - SUSPENSION:REAR
Posted on: 1996-11-27
Description
Vehicle description: school buses and heavy duty trucks equipped with rear axle assemblies produced by dana spicer. Certain rear axle assemblies were improperly heat treated which could allow pinion breakage at the pinion threads.
Consequence
Cracks can initiate and result in separation of the threaded end of the pinion resulting in separation of the yoke and drive line from the rear axle increasing the risk of a vehicle accident.
Corrective Action
Dealers will replace the rear axle carrier/pinion assembly.
Notes
Owner notification:owner notification will begin december 20, 1996. Note:owners who take their buses to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact navistar at 1-800-448-7825.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #2 - SUSPENSION:REAR
Posted on: 1996-12-19
Description
The drive axle housings consist of a plate steel center section and two forged spindles, one of which is welded to each end of the center section. Each spindle contains a keyway slot in which the locking tab for the wheel bearing nut locking mechanism is inserted. The length of the keyway slot may not be long enough to accommodate the tab causing the tab to be deformed or damaged during installation.
Consequence
This locking tab prevents the wheel bearing nut from loosening during vehicle operation. If this tab is deformed, the nut can loosen allowing the wheel to separate from the axle increasing the risk of a vehicle accident.
Corrective Action
Dealers will replace the drive axle housing nuts with a conventional wheel nut hardware system.
Notes
Owner notification:owner notification began december 10, 1996. Note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact navistar at 1-800-448-7825.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #3 - STEERING:WHEEL AND HANDLE BAR
Posted on: 1996-08-28
Description
The steering column used was incorrectly manufactured. The tube portion of the steering column has a welded end with a specified length of 5.5 inches. A 3.5 inch welded end was used by mistake. With the shorter end, it is possible there is insufficient engagement of the male end into the tube portion and separation of the column could occur.
Consequence
Should the column separate, the operator would lose steering control increasing the potential for a vehicle accident.
Corrective Action
Dealers will replace the incorrectly built steering column with a new correctly built steering column.
Notes
Owner notification:owner notification is expected to begin september 10, 1996.note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact navistar at 1-800-448-7825.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #4 - SEATS
Posted on: 2003-03-17
Description
On certain heavy duty trucks equipped with bostrom driver seat models 910, 910sc, or 914 and international's parking brake code 04036, if someone outside the cab adjusts/slides the driver's seat to its most forward position, with the parking brake set, the seat will contact and release the parking brake lever.
Consequence
If the parking brake is accidentally released, the vehicle could move unexpectedly, increasing the risk of a crash.
Corrective Action
Dealers will install a stop-bracket on the seat track to limit the travel of the seat so that the seat cannot release the parking brake lever. Owner notification began on march 31, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
Notes
International recall no. 03503.(previously 01503)customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).