11 recalls found. |
DEFECT #1 - STEERING:RACK AND PINION
Posted on: 2002-11-06
Description
Certain passenger vehicles and mini vans have lower pinion bearings in the power rack and pinion assembly in which the retainer tabs were not crimped properly. These and some other retainers used in vehicles assembled between january 1, 1996 and october 31, 1997, could fail and permit the ball bearings to escape.
Consequence
If this occurs, the pinion shaft can be forced upward during left turns and back down as the steering wheel is moved back and to the right. If the pinion shaft moves further, the driver will need to exert more effort to turn the steering wheel, similar to a vehicle without power assisted steering. If the pinion shaft moves even further, the driver will require much higher effort to turn left and may not be able to turn the wheel as much as intended. With the maximum pinion shaft movement, which requires internal gear component damage, the driver can encounter high resistance to turning left, followed by unintended power assist to the right. In any of these conditions, a crash could occur.
Corrective Action
Dealers will install a new lower pinion bearing unless inspect of the existing bearing indicates that replacement of the gear assembly is necessary. Owner notification began january 24, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737, or oldsmobile at 1-800-442-6537.
Notes
Gm recall no. 02049.also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 2000-02-29
Description
Vehicle description: passenger vehicles equipped with bi-fuel compressed natural gas (cng) vehicles. The cng fuel line and the cng high pressure regulator coolant lines can contact other fuel (gasoline) and brake lines on the vehicle. Abrasion from contact can cause a leak in the brake pipe, fuel pipe, or both.
Consequence
Abrasion from contact can cause a leak in the brake pipe, fuel pipe, or both. A brake fluid leak could disable a portion of the brake system, causing longer stopping distances. Gasoline leaking from a fuel pipe, in the presence of an ignition source, could cause a vehicle fire.
Corrective Action
Dealers will inspect and reposition the cng fuel and coolant pipes and reposition/repair any damaged fuel or brake pipes as necessary.
Notes
Owner notification began march 17, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - WHEELS:LUGS/NUTS/BOLTS
Posted on: 1997-12-03
Description
Vehicle description: passenger vehicles. The wheel lug nuts were not tightened securely resulting in a fracture of the wheel studs.
Consequence
The wheel could separate from the vehicle. If the vehicle were in motion, a vehicle crash could result.
Corrective Action
Dealers will inspect the torque of all wheel nuts and, if necessary, tighten any that may be below required torque.
Notes
Dealer notification began november 21, 1997. All vehicles are still at dealers.no owners are involved.
DEFECT #4 - FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Posted on: 2007-02-26
Description
Certain delphi aftermarket fuel pump modules / module reservoir assemblies (mra) that were sold for use on the above listed vehicles. During production the mras vent and fuel return tubes were reversed. This condition can result in the vehicle not running correctly (idle rough and/or stall) due to an overly rich fuel blend or the vehicle's evaporative emission carbon canister may leak fuel.
Consequence
A stalled vehicle can increase the risk of a vehicle crash. A fuel leak can result in a fire.
Corrective Action
Delphi will notify owners and replace the defective mras free of charge. The recall began on march 20, 2007. Owners can contact delphi at 1-877-335-7443.
Notes
This recall only pertains to aftermarket delphi fuel pump modules and has no relation to any original equipment installed on vehicles manufactured by general motors corporation.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #5 - ELECTRICAL SYSTEM:IGNITION:SWITCH
Posted on: 2004-02-05
Description
On certain passenger vehicles. If the engine fails to start and the driver holds the key in the start position for an extended period, high current flows through the ignition switch, and sometimes produces enough heat to melt internal switch parts.
Consequence
If the switch is damaged, a fire could occur in the steering column, even with the engine off and the key removed. The fire could spread to the interior of the car, which could injure occupants or cause damage to adjoining structures.
Corrective Action
Dealers will install a relay kit in these vehicles to prevent high current from flowing through the ignition switch, and check that your car will start with a properly charged battery and, if necessary, replace the ignition switch. Owner notification will begin on march 1, 2004. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-630-2438, pontiac at 1-800-620-7668, buick at 1-866-608-8080, or oldsmobile at 1-800-630-6537. Customers can also check their vehicle online by going to www.mygmlink.com and entering the vehicle's identification number.
Notes
Gm recall no. 04002.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #6 - FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
Posted on: 2007-03-12
Description
Certain delphi fuel pressure regulators, p/nos. Fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. The universal pressure regulators (upr) were produced without an o'ring and retainer.
Consequence
Fuel may leak, possibly resulting in a fire.
Corrective Action
Delphi will notify owners and replace the upr free of charge. The recall began on april 23, 2007. Owners can contact delphi at 877-411-8770.
Notes
This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #7 - EXTERIOR LIGHTING
Posted on: 2006-06-05
Description
Certain ck motorsports combination headlights, clear corner, bumper, and side marker lights sold as replacement lamps for use on the passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Corrective Action
Ck motorsport will notify owners and replace the noncompliant lamps free of charge. The recall began on july 1, 2006. Owners may contact ck motorsport at 1-909-610-7211.
Notes
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.for more information on the lamp model numbers, click on document search and view document titled lamp model numbers.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #8 - EXTERIOR LIGHTING
Posted on: 2006-03-23
Description
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Corrective Action
Pro-a motors will notify owners and offer to repurchase the lamps. The recall began on april 3, 2006. Owners may contact pro-a motors at 323-838-2988.
Notes
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled lamp model numbers.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #9 - STEERING
Posted on: 2008-10-20
Description
Dorman products is recalling 3,900 intermediate steering shafts dorman part nos. 425-151, 425-152, and 425-153, (sold under dorman's oe solutions brand name), balkamp #'s 7-3057, 7-3058, 7-3059 (sold under the napa brand name), and platinum parts #'s 2425151, 2425152, and 2425153 manufactured during the month of september 2007. These replacement steering shafts can be used on the vehicles listed above. The weld connecting the inner tube to the outer tube may be defective.
Consequence
If the weld fails, loss of steering could result, possibly resulting in a vehicle crash.
Corrective Action
Dorman will notify owners and replace the steering shafts free of charge. The recall began on october 16, 2008. Owners may contact dorman toll free at 1-800-523-2492.
Notes
This recall only pertains to dorman's oe solutions brand name, balkamp's napa brand, and the platinum brand steering shafts and has no relation to any original equipment installed on vehicles manufactured by general motors corporation.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #10 - EXTERIOR LIGHTING
Posted on: 2009-04-07
Description
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. These lamps do not contain the required amber side reflectors.
Consequence
Decreased lighting visibility may result in a vehicle crash.
Corrective Action
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.
Notes
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under document search located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #11 - EXTERIOR LIGHTING:HEADLIGHTS
Posted on: 2009-05-11
Description
Dope, inc. Is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. These lamps do not contain the required amber side reflectors.
Consequence
Decreased lighting visibility may result in a vehicle crash.
Corrective Action
Dope, inc. Will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on july 28, 2009. Owners may contact dope, inc. At 1-626-272-1798.
Notes
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under document search located at the bottom of your screen. Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .