|
|
Recalls for
1998 Ford Contour
|
12 recalls found.
|
DEFECT #1 - SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
Posted on: 2001-08-23
Description
This is not a safety recall in accordance with the safety act. However, it is deemed a safety improvement campaign by the agency. Vehicle description: 1998 ford contour/mercury mystique passenger vehicles built at the kansas city assembly plant. The front coil springs could potentially fracture due to corrosion.
Consequence
Some tires have deflated due to contact with a broken spring.
Corrective Action
Ford is extending the warranty for front coil spring replacement for the front coil springs for 10 years from original date of sale of a vehicle or 150,000 miles, whichever comes first.
Notes
Ford has decided to conduct a service campaign to extend the warranty coverage for the front coil springs. Owners can contact ford at1-866-436-7332, concerning this program. DEFECT #2 - SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
Posted on: 2001-08-23
Description
Vehicle description: passenger vehicles built at the kansas city assembly plant and originally sold in or currently registered in the states of connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, and wisconsin, and the district of columbia. The front coil springs may fracture as a result of corrosion in high corrosion environments. Depending on the location of the fracture, a broken spring could move past the spring seat and contact a front tire.
Consequence
Some tires have deflated due to contact with a broken spring.
Corrective Action
Dealers will install spring catcher brackets. Owner notification began october 23, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). DEFECT #3 - ELECTRICAL SYSTEM
Posted on: 2001-07-13
Description
On certain my 1996-1998 passenger vehicles built at the kansas city, cuautitlan assembly plants or on my 1999 passenger vehcles built at the automotive alliance international assembly plants, the rough surface of the heater blower resistor's stainless steel blades can damage the copper surface of the wiring harness connector. The damage could, over time, cause increased resistance in the connector and, due to subsequent terminal relaxation, result in an open circuit condition.
Consequence
The open circuit could lead to electrical arcing that could melt the connector housing material creasing the potential for a fire.
Corrective Action
Dealers will install a new heater blower resistor and a new wire jumper harness. Owner notification began august 29, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
Notes
Ford recall no.01s22.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). DEFECT #4 - FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY
Posted on: 2000-10-31
Description
Vehicle description: bi-fuel vehicles. These vehicles may have a fuel tank filler pipe grommet that could have been damaged during the installation of the bi-fuel system. If the grommet is damaged, fuel could leak. Fuel leakage in the presence of an ignition source could result in a fire. Dealers will replace the fuel tank filler pipe grommet.
Consequence
If the grommet is damaged, fuel could leak. Fuel leakage in the presence of an ignition source could result in a fire.
Corrective Action
Dealers will replace the fuel tank filler pipe grommet.
Notes
Owner notification began november 30, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). DEFECT #5 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
Posted on: 2000-03-14
Description
Vehicle description: passenger vehicles not equipped with the anti-lock braking system (abs). A pressure conscious reducing valve (pcrv) in the rear brakes may be subject to corrosion and result in malfunction, when operated in areas that use salt compounds on the roadway for de-icing or dust control.
Consequence
If both pcrv's malfunction, vehicle handling could be adversely affected during braking as a result of the rear wheels locking, increasing the risk of a crash.
Corrective Action
Dealers will install improved pcrv's in the rear brake system. This recall was expanded in september 2000 to include 1999 and 2000 ford contour, mercury mystique and cougar vehicles.
Notes
Owner notification began april 3, 2000 for the 1996-1998 model vehicles and on october 11, 2000, for the 1999-2000 model vehicles.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). DEFECT #6 - EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
Posted on: 1999-05-10
Description
Vehicle description: passenger vehicles. The terminals at the headlight switch and wiring harness connector can experience heat damage as a result of overheating.
Consequence
The damage could result in distortion of the terminal causing an open circuit in the instrument panel illumination, parking lamp, and tail lamp circuits.
Corrective Action
Dealers will install a headlamp switch wiring connector containing bronze terminals and an inspection, and replacement if necessary, of the headlamp switch.
Notes
Owner notification began july 16, 1999. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). DEFECT #7 - VEHICLE SPEED CONTROL
Posted on: 1999-07-21
Description
Vehicle description: passenger vehicles. The accelerator cable may have been manufactured with a burr on or near the end of the cable sleeve interior. This burr could fray the core wire resulting in the accelerator not returning to idle when the accelerator is released.
Consequence
This condition can result in the throttle sticking, binding, or causing high engine rpm.
Corrective Action
Dealers will install a revised accelerator cable that has a flared conduit sleeve end and molded on end fitting.
Notes
Owner notification began august 17, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). DEFECT #8 - AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
Posted on: 1999-09-23
Description
Vehicle description: passenger vehicles. The air bag sensor wiring pigtail insulation can become brittle and crack over time due to accumulation of water in the pigtail protective convolute in combination with high underhood temperatures related to the routing of the wiring pigtail near the radiator. This can result in environmental stress cracking of the insulation.
Consequence
In some cases, the air bag warning light can illuminate and the air bag supplemental restraint system disabled.
Corrective Action
Dealers will install air bag sensors with revised wiring insulation. In addition, vehicles which have the air bag warning light illuminated will have a new air bag diagnostic monitor installed.
Notes
Ford recall no. 99s23. Owner notification began september 27, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). DEFECT #9 - POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT
Posted on: 1998-09-25
Description
Vehicle description: passenger vehicles. The floor shift automatic transmission control can be damaged if subjected to certain interior cleaning products. The gear position indicator can deteriorate and not correctly indicate the actual gear position.
Consequence
This condition can result in incorrect gear selection.
Corrective Action
Dealers will replace the automatic transmission floor shift control.
Notes
Owner notification began november 20, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). DEFECT #10 - EXTERIOR LIGHTING:HEADLIGHTS
Posted on: 1998-02-25
Description
Vehicle description: passenger vehicles. The text and/or graphics for the vehicle headlamp aiming instructions provided in the owner guides are not sufficiently clear. This does not meet the requirements of fmvss no. 108, lamps, reflective devices, and associated equipment.
Consequence
If the headlamp assemblies are replaced, customers may be confused by the aiming instructions provided in the owner guides causing the headlamps to be improperly aimed.
Corrective Action
Owner guides containing revised aiming instructions will be mailed to owners of these vehicles.
Notes
Owner notification is expected to begin march 23, 1998. Owners who do not receive the free owner guide within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). DEFECT #11 - SERVICE BRAKES, HYDRAULIC
Posted on: 2006-03-13
Description
Certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. These brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. Only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. When subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak.
Consequence
Loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.
Corrective Action
Affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. The recall began on march 20, 2006. Owners can contact affina group customer service at 1-800-323-0354.
Notes
This recall only pertains to aftermarket napa, raybestos, ac delco, aimco, carquest, and bendix brake hydraulic master cylinders and has no relation to any original equipment installed on daimlerchrysler or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. DEFECT #12 - SUSPENSION
Posted on: 2008-04-17
Description
Federal mogul is recalling 6,903 aftermarket ball joint assemblies shipped between november 9, 2007 and march 26, 2008, which may have been packaged with incorrect nuts. The part numbers packaged with incorrect nuts are: k7147, k7329, k8683, and 104353. These parts were made for use on the various vehicles listed above.
Consequence
The nuts included in the packaging for these ball joint assemblies are missing the intended prevailing torque (self-locking) feature. If the incorrect nut was to become loose, the joining members may loosen leading to a separation of the ball joint. This may result in loss of vehicle control, possibly resulting in a vehicle crash.
Corrective Action
Federal mogul will notify owners and replace the parts free of charge. The recall began on may 22, 2008. Owners can contact federal mogul at 877-489-6659.
Notes
This recall only pertains to aftermarket ball joint assemblies and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.