11 recalls found. |
DEFECT #1 - ELECTRICAL SYSTEM:BATTERY
Posted on: 2001-03-22
Description
Vehicle description: transit buses equipped with vanner 60 series battery equalizers. The equalizer could fail to operate properly and cause malfunction of the battery charging system.
Consequence
Without fusing, the equalizer may melt, burn, or smoke, possibly resulting in a fire or a smoke filled bus, thus necessitating a passenger evacuation of the bus. The failure mode can cause operator distraction, and/or possible personal injury.
Corrective Action
Orion will notify owners to inspect their buses for certain equalizers by the date code. The affected equalizers will be replaced by vanner. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact vanner at 1-800-227-6937.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - UNKNOWN OR OTHER
Posted on: 1999-09-23
Description
Vehicle description: transit buses. Failure of a soft seat check valve in wheelchair lifts provided by lift-u, may allow the front and rear platform barriers to return to a horizontal position from the vertical position they are supposed to be locked in.
Consequence
This could allow a mobility aid to roll off of the lift platform injuring its occupant. Lift-u will replace the soft seat check valves.
Corrective Action
Lift-u will replace the soft seat check valves.
Notes
Orion recall no. Obi-9901.owner notification began june 25, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact lift-u at 1-209-838-2400 or orion bus at 1-315-768-8101.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - UNKNOWN OR OTHER
Posted on: 1998-09-25
Description
Vehicle description: transit buses equipped with wheel chair barriers. The wheel chair barriers are attached to the floor structure with a bolt threaded into the floor structure. In the case of a frontal crash, with the wheel chair position occupied, the bolt threads could strip allowing movement of the wheel chair barrier.
Consequence
This condition could allow movement of the wheel chair which could cause personal injury, or death, to the wheel chair occupant.
Corrective Action
Dealers will replace the existing wheel chair barrier leg mounting bolts with new bolts, nuts and washers.
Notes
Owner notification is expected to begin during october 1998. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact orion at 1-905-403-1111.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - ELECTRICAL SYSTEM:WIRING
Posted on: 1998-09-25
Description
Vehicle description: transit buses equipped with electric engine starters. The power cables are routed across the back of the engine and fastened to the engine bulkhead. The cable may not be adequately fastened, chaffing the cable, and causing an electrical short.
Consequence
This condition could possibly start a fire in the engine compartment.
Corrective Action
Dealers rerouted the wiring in the engine compartment.
Notes
Owner notification began april 15, 1998.all owners have been notified.no further action is required on this recall.
DEFECT #5 - STEERING:HYDRAULIC POWER ASSIST:PUMP
Posted on: 1998-07-31
Description
Vehicle description: transit buses equipped with sunsource/fauver tandem hydraulic pumps. The hydraulic piston pump is driven by the engine and a shaft out of the back of the pump providing power to the power steering pump. The shafts are connected together with a coupling. This coupling is fitted with two retainer clips which keeps it centered between the two pumps. These buses were shipped missing the coupling retainer clips.
Consequence
Excessive movement of the coupling can disengage the two pump shafts, causing loss of power steering.
Corrective Action
Dealers are inspecting and retrofitting the couplings on these pumps.
Notes
Owner notification has begun.all owners have been notified.
DEFECT #6 - EQUIPMENT ADAPTIVE
Posted on: 2007-02-05
Description
On certain transit buses equipped with lift-u wheelchair lifts, it is possible for a person to wedge their feet under the solid bar barrier linkage.
Consequence
While sitting in a wheelchair, a person with no shoes and who does not have control of their feet could twist their feet and get them forced under the linkage which could result in an injury.
Corrective Action
Daimlerchrysler commercial is working with lift-u to repair these buses (please see 06e-093). Owners will receive a free repair kit along with installation instructions free of charge. Owners may contact lift-u at 209-838-2400 or orion bus at 905-403-7807.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #7 - ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO-CHARGER
Posted on: 2005-02-01
Description
On certain transit buses equipped with detroit diesel series 50 engines, the turbocharger can fail allowing lubricating oil to enter the exhaust system.
Consequence
In the event the turbocharger fails, a fire may occur in the engine compartment resulting in property damage or injuries.
Corrective Action
Detroit diesel is conducting the owner notification and remedy for this campaign. Dealers will repair the engine and install an exhaust temperature sensor to prevent the possibility of an exhaust or engine compartment fire. Owners may contact detroit diesel corporation at 313-592-5791 or orion at 905-403-7832.
Notes
Orion & detroit diesel recall no. 04c-2.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #8 - VEHICLE SPEED CONTROL
Posted on: 2004-03-26
Description
On certain buses equipped with cummins electronic control modules on the l10g engines, the ecm does not have the ability to detect a throttle fail-safe engine shutdown command. This could result in an unanticipated, uncommanded open throttle condition without warning.
Consequence
If this event occurs, the vehicle operator will not have control of the engine speed, possibly resulting in a vehicle crash.
Corrective Action
Cummins will notify the customers and replace the ecm. Owners should contact cummins at 1-800-343-7357 or orion at 1-800-658-2871.
Notes
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #9 - STRUCTURE
Posted on: 2004-11-16
Description
Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 217, bus emergency exits and window retention and release. During subsequent closing of an emergency exit the moving window frame interferes with the jam frame stop located in mid span along the lower edge of the window frame.
Consequence
During the use of an emergency exit window, a window may not open after applying the required forces allowing a person to escape in the event of an emergency.
Corrective Action
Dealers will install two aluminum blocks each attached by two screws. The moving window frame will not interfere with the jam frame stop. The recall began may 1, 2005. Owners should contact orion at 905-403-7832, ext. 3335.
Notes
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #10 - VISIBILITY:GLASS, SIDE/REAR
Posted on: 2003-04-01
Description
Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 217, bus emergency exits and window retention and release. The handle pull force exceeds the 89n force to release the emergency window. Additional force is required to release the window.
Consequence
In the event of a crash, an occupant may have difficulty opening the emergency exit window, increasing the risk of personal injury or death.
Corrective Action
Dealers will repair these windows. Owner notification began june 1, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact orion at 1-800-492-2116.
Notes
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #11 - POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/LINKAGE
Posted on: 2010-01-21
Description
Daimler buses is recalling certain orion transit buses equipped with the morse remote throttle control. The morse remote throttle control panel is located in the engine compartment and a switch on it is labeled, throttle; off or front and on or rear selecting the active engine control station. If a person operating the engine from the rear position (at the engine) fails to place the switch in the off or front position and the engine rpm was set to above idle during maintenance for example, when the bus is started from the driver's station the engine could change to the higher rpm resulting in unwanted engine power.
Consequence
The bus could accelerate at a higher rate than anticipated increasing the risk of a crash.
Corrective Action
Daimler will provide instructions to modify the wiring to the morse throttle control switch. This service will be performed free of charge. The safety recall began on april 1, 2010. Owners may contact daimler buses at 1-800-716-7466.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .