5 recalls found. |
DEFECT #1 - FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
Posted on: 2000-09-14
Description
Vehicle description: mini vans built with 3.3l and 3.8l engines have fuel rails with nitrole rubber o-ring seals that can degrade over time. Fuel leakage from the underhood fuel injection fuel rail could result, increasing the likelihood of a vehicle fire.
Consequence
Fuel leakage in the presence of an ignition source can result in a fire.
Corrective Action
Dealers will install a seal on the vehicle fuel rails to prevent external leakage of fuel from the fuel rail crossover tube, should the existing o-rings continue to degrade. Owner notification began on january 25, 2002. Due to the large quantity of vehicles involved in this campaign, the owner notification will be phased over the next several months. However, if a vehicle is leaking fuel from the o-rings, the vehicle should be taken into a dealer to have this repaired as soon as possible. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - EXTERIOR LIGHTING:HEADLIGHTS
Posted on: 1999-05-12
Description
Vehicle description: mini vans built for fleet sales only. The headlamp module does not identify the park lamp as drl as requirement of fmvss 108, lamps, reflective devices, and associated equipment.
Consequence
These vehicles do not comply with requirements of fmvss no. 108.
Corrective Action
All fleet owners/operators will be mailed non-removable decals with the required drl letters.
Notes
Owner notification began may 31, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - AIR BAGS
Posted on: 2004-10-12
Description
On certain minivans, the driver's air bag may become disabled due to a failure of the clockspring, which is located in the hub of the steering wheel.
Consequence
This condition will manifest itself through illumination of the air bag warning lamp, and could eventually result in a driver's air bag open circuit, if the part is not replaced in a reasonable amount of time.
Corrective Action
Dealers will replace the clockspring assembly on all covered vehicles with 70,000 miles or less. For those vehicles with more than 70,000 miles, daimlerchrysler will offer an extended lifetime warranty under which it will replace the clockspring at no charge if it fails. Daimlerchrysler will also reimburse owners who have paid to have the clockspring replaced on their vehicles. The recall began on october 12, 2004. Owners should contact daimlerchrysler at 1-800-853-1403.
Notes
Daimlerchrysler recall no. D17.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Posted on: 2006-11-02
Description
Certain airtex fuel pump modules, p/nos. E7089m, e7094m, e7113m, and e7129m, manufactured between june 1 and september 24, 2006. These fuel pump modules were sold as aftermarket for use in certain daimlerchrysler vehicles listed above. Silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.
Consequence
Fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.
Corrective Action
Airtex will notify owners and replace the defective fuel pump modules free of charge. The recall began on october 18, 2006. Owners may contact airtex toll-free at 1-866-867-3759.
Notes
This recall only pertains to aftermarket fuel pump modules and has no relation to any original equipment installed on vehicles by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #5 - VISIBILITY:GLASS, SIDE/REAR
Posted on: 2007-12-11
Description
Certain curved tempered replacement glass manufactured by hangzhou safety glass ltd and supplied to safelite by auto temp inc., identified as dot-430, and sold for use on certain domestic and foreign vehicles may not break into small pieces as expected of tempered glass and fails to conform to federal motor vehicle safety standard no. 205, glazing materials.
Consequence
In the event of a vehicle crash, the occupant(s) may be seriously injured by shattered glass.
Corrective Action
Safelite will notify its retail customers and replace the glass free of charge. Retail customers can contact safelite toll free at 1-888-843-2906. Safelite will notify its wholesale customers and reimburse wholesale customers for current inventory and at a specified rate for replacing their customer's glass. Wholesale customers can contact safelite's wholesale division, service autoglass toll free at 1-888-246-6298. The recall began on january 15, 2008.
Notes
This recall only pertains to certain curved tempered replacement glass manufactured by hangzhou safety glass, ltd. (dot-430) and supplied to safelite by auto temp inc., and has no relation to any original equipment installed on the vehicles listed above. Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.