7 recalls found. |
DEFECT #1 - ELECTRICAL SYSTEM:BATTERY
Posted on: 2001-03-01
Description
Vehicle description: transit buses equipped with vanner 60 series battery equalizers. The equalizer could fail to operate properly and cause malfunction of the battery charging system.
Consequence
Without fusing, the equalizer may melt, burn, or smoke, possibly resulting in a fire or a smoke filled bus, thus necessitating a passenger evacuation of the bus. The failure mode can cause operator distraction, and/or possible personal injury.
Corrective Action
Prevost will notify owners to inspect their buses for certain equalizers by the date code. The affected equalizers will be replaced. Owner notification began november 29, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact prevost at 1-418-831-2046 or vanner at 1-800-227-6937.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - SUSPENSION
Posted on: 2000-11-29
Description
Vehicle description: transit coaches. The reinforcement brackets were not welded on the tag axle.
Consequence
This condition could result in a loss of vehicle control, increasing the risk of a crash.
Corrective Action
Dealers will weld the brackets on the tab axle.
Notes
Owner notification began november 21, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact prevost at 1-418-831-2046.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - STEERING:WHEEL AND HANDLE BAR
Posted on: 2000-05-10
Description
Vehicle description: transit buses and bus shells. Some vehicles are fitting with a steering column adjustment plate.
Consequence
This could lead to loss of vehicle control.
Corrective Action
Dealers will inspect the vehicles for an adjustment plate and will replace the adjustment plate if necessary.
Notes
Owner notification is expected to begin during may 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact prevost at 1-418-883-3391. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 1999-04-29
Description
Vehicle description: transit buses and bus shells. Some brake line hoses may have been manufactured using heater hose material instead of brake line hose material. Heater hoses are not appropriate for use as brake lines because the operating pressure of the braking system is much higher than that of the heating system.
Consequence
This could result in sudden brake line failure.
Corrective Action
Dealers will replace the heater hoses with correct brake line hoses.
Notes
Owner notification is expected to begin during april 1999. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact prevost at 1-418-883-3391. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #5 - VISIBILITY:GLASS, SIDE/REAR
Posted on: 1999-10-27
Description
Vehicle description: transit coaches. If a front collision should happen, the emergency exit window would unlock if the window stops strike the locking levers and break them, due to a relative displacement between these parts.
Consequence
A vehicle occupant could be injured.
Corrective Action
Dealers will cut the top of the stop.
Notes
Prevost recall nos. Sr99-36/sr99-36a.owner notification is expected to begin during october 1999. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact prevost at 1-418-883-3391.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #6 - SUSPENSION:FRONT
Posted on: 1998-10-07
Description
Vehicle description: transit buses. The bolts fixing the radius rod locking tab plates were not lubricated before being tightened.
Consequence
Improper tightening can cause loosening of the attachment over a period of time increasing the risk of loss of control of the vehicle.
Corrective Action
Dealers will inspect the bolts, lubricating them, installing a new locking tab plate, and retightening the bolts.
Notes
Owner notification began june 18, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact prevost at 1-418-883-3391. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #7 - STEERING:COLUMN
Posted on: 2003-03-18
Description
On certain motor coaches and motor homes, the steering columns may be missing the lower bolt and nut. A replacement bolt and nut was installed to correct this situation on the production line. If a replacement bolt has been used and not tightened properly, the column may come out of the input shaft when the steering column adjustment mechanism is used.
Consequence
In such a case, a loss of steering would occur.
Corrective Action
Dealers will verify the size of the bolt and nut and replace them if needed. Owner notification began april 4, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact prevost at 1-418-831-5432.
Notes
Prevost recall no. Sr03-06.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).