12 recalls found. |
DEFECT #1 - AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
Posted on: 2002-07-22
Description
On certain pickup and utility trucks, some of these vehicles have an air bag sensing diagnostic module (sdm) which contains an anomaly that could result in the driver and passenger's air bag failing to deploy during certain frontal crashes.
Consequence
In a vehicle crash, front seat occupants may receive more severe injuries.
Corrective Action
Dealers will recalibrate the sdm on the affected vehicles. Owner notification began august 28, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.
Notes
Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 2000-10-30
Description
Vehicle description: light duty pickup trucks and sport utility vehicles. Some of these vehicles have a clearance condition between the front right-hand brake pipe and the body cross sill that could decrease to the point of allowing contact during the life of the vehicle. If contact occurs and the brake pipe becomes damaged, in half of the brake system there can be a loss of brake fluid and pressure. The brake warning lamp will be activated when the brake fluid level reaches the indicator limit.
Consequence
During braking, the pedal will be lower than normal and stopping distances will be longer. If this occurs when stopping distance is limited, a crash could occur.
Corrective Action
Dealers will inspect the front right-hand brake pipe for wear. If there are signs of wear, this section of the brake pipe will be replaced with a new designed brake pipe section. If there are not signs of wear on the brake pipe, the dealer will install a spacer clip to ensure sufficient clearance between the brake pipe and the body cross sill.
Notes
Owner notification began february 5, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
Posted on: 2000-08-24
Description
This is not a safety recall in accordance with the safety act. However, it is deemed a safety improvement campaign by the agency. Vehicle description: 1/2 ton light duty pickup trucks. On certain trucks, failure to follow the service procedure set forth in the service manual for removal of the front brake caliper can result in movement of the front brake hose relative to its knuckle mounting bracket. If this movement results in increased length between the bracket and the banjo fitting that attaches to the brake caliper, it is possible for the brake hose to come in contact with the wheel rim.
Consequence
This contact with the wheel rim could, in time, cause the brake hose to become worn to the point that brake fluid leakage could occur. If this occurred, loss of front brakes is possible.
Corrective Action
Dealers will attach a notice label to the front brake hoses stating that the calipers must be supported when removed.
Notes
Gm has decided to conduct a service program to install a label on the hose with warning and recommendations to support the brake calipers when removing them.owners can contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782, concerning this program.
DEFECT #4 - SERVICE BRAKES, HYDRAULIC:ANTILOCK
Posted on: 2000-02-29
Description
Vehicle description: light duty pickup trucks equipped with 4-wheel disc brakes. Some of these vehicles have an antilock brake system (abs) motor containing an out-of-specification spring clip. This clip could allow the motor bearing to become misaligned. If misalignment occurs, eventually the abs would be non-functional.
Consequence
The base brakes would remain fully functional, but the dynamic rear proportioning (drp) system, which optimizes front to rear brake balance, would become inoperative.
Corrective Action
Dealers will replace the brake pressure module valve assembly.
Notes
Gm recall no. 00013.owner notification began march 27, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #5 - EQUIPMENT
Posted on: 2004-03-30
Description
Aftermarket pickup truck over-the-rail bedliners manufactured for installation on 1999-2004 chevrolet silverado and gmc sierra pickup trucks. The toggle wing assembly used to attach the bedliner to the truck bed is not engaging fully in the stake pocket of the pickup truck.
Consequence
The bedliner can become detached from the pickup while it is motion, possibly endangering following motorists or pedestrians.
Corrective Action
Durakon will issue a press release in attempt to notify customers that could have purchased the defective bedliner. If you purchased either a durakon allstar of patriot overrail bedliner since august 1, 2003, for 1999 to 2004 chevrolet silverado or gmc sierra trucks, or purchased one of these pickup trucks with either brand bedliner already installed, you should return to an authorized durakon dealer so that the bedliner can be inspected and, if necessary, repaired with a newly designed toggle wing fastening system, or if required, replaced with a new bedliner free of charge. Please call the durakon hotline at 1-800-933-4200 to find the nearest authorized durakon dealer.
Notes
This recall only pertains to aftermarket overrail bedliners and has no relation to any original equipment installed on chevrolet silverado and gmc sierra pickup trucks by general motors.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #6 - SERVICE BRAKES, HYDRAULIC:ANTILOCK
Posted on: 2005-08-29
Description
Certain pickup trucks and sport utility vehicles may experience unwanted antilock brake system (abs) activation. This condition is more likely to occur in environmentally corrosive areas. This recall will be launched in the salt belt states of connecticut, delaware, illinois, indiana, iowa, maryland, massachusetts, maine, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia only.
Consequence
This can cause increased stopping distances during low-speed brake applications, which could result in a crash.
Corrective Action
Dealers are to remove the wheel speed sensor and thoroughly clean the wheel speed sensor mounting surface on the bearing, apply rust inhibitor to the cleaned surface, grease the mounting surface, reinstall the wheel speed sensor, and check the peak-to-peak output voltage to ensure the wheel speed signal is within specifications. The recall began september 22, 2005. Owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Notes
Gm recall no. 05068. Gm revised the involved vehicles by amending the original 573 report on october 4, 2005. Gm revised the original 573 report on december 16, 2005, to include additional states and vehicle population.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #7 - STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
Posted on: 2004-03-22
Description
On certain pickup trucks and sport utility vehicles, the galvanized steel tailgate support cables that retain the tailgate in the full open (horizontal) position may corrode, weaken, and eventually fracture. If both cables fractured, the tailgate would suddenly drop and strike the top surface of the rear bumper.
Consequence
Anyone sitting or standing on the horizontal surface of the tailgate when both cables fractured could be injured by falling from the tailgate. On vehicles that have had the bumper removed, the tailgate may drop even lower. Additionally, if there is cargo on the tailgate the cargo may fall off if the support cables fracture.
Corrective Action
Dealers will replace the cables. Interim owner notification began on april 7, 20004. The recall began on september 24, 2004, when replacement parts were available, and will continue through october 29, 2004. Owners should contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463, or visit www.mygmlink.com, and enter your vehicle identification number.
Notes
Gm recall no. 04007.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #8 - STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
Posted on: 2006-03-08
Description
Certain pickup trucks have galvanized-braided-steel tailgate support cables used to support the tailgate in the full open (horizontal) position. Over time these cables can corrode and fracture when loads are applied to them.
Consequence
If one cable fractures, the remaining cable may retain the tailgate in a horizontal position. If both cables fracture, the tailgate would drop and strike the top surface of the rear bumper. If anyone is sitting or standing on the horizontal surface of the tailgate when both cables fractured, they could fall and be injured. On vehicles without a bumper, the tailgate may drop to a lower position.
Corrective Action
Dealers will replace the galvanized support cables with stainless steel support cables. In addition, dealers are to inspect the tailgate hinge and replace it, if necessary. The recall is expected to begin during april 2006. Owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Notes
Gm recall no. 06019.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #9 - POWER TRAIN:DRIVELINE:DRIVESHAFT
Posted on: 2005-01-10
Description
Some pickup trucks, vans, and sport utility vehicles equipped with a hydraulic pump driveshaft that can fracture, resulting in immediate loss of hydraulic power steering assist. On certain vehicles equipped with hydro-boost power brakes, the same condition can result in loss of power assist for braking after the reserve pressure is depleted.
Consequence
An inoperative pump can cause increased steering effort, and in hydro-boost equipped vehicles also increased braking effort, but does not completely eliminate the ability to steer or slow the vehicle.
Corrective Action
Dealers will replace the hydraulic pump. The campaign began on february 14, 2005. Owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Notes
Gm campaign no. 05001.this action is deemed a safety improvement campaign and is not being conducted under the safety act.the company has informed nhtsa that it will provide the modifications described above free of charge.
DEFECT #10 - PARKING BRAKE
Posted on: 2005-04-22
Description
On certain pickup trucks equipped with manual transmissions and built with either pbr parking brake systems or trw parking brake systems, the parking brake friction linings may wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.
Consequence
If the parking brake does not hold, unintended vehicle movement could occur, which could result in a crash.
Corrective Action
Dealers will install a low-force spring clip retainer for vehicles equipped with a pbr parking brake system. On vehicles equipped with the trw parking brake system, dealers will install a redesigned parking brake cable assembly. The recall began on july 29, 2005. Owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Notes
Gm recall no. 05042.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #11 - EQUIPMENT:ELECTRICAL
Posted on: 2007-08-29
Description
Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. Due to incorrect wiring of the harness, the trailer lights may not operate properly.
Consequence
If the trailer lights are not working properly, a vehicle crash can occur.
Corrective Action
All of the defective tow packages are still at the distributor level and have not been sold to any consumers.
Notes
This recall only pertains to aftermarket cequent tow packages and has no relation to any original equipment installed on daimlerchrysler, gmc, or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #12 - EXTERIOR LIGHTING:HEADLIGHTS
Posted on: 2009-05-11
Description
Dope, inc. Is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. These lamps do not contain the required amber side reflectors.
Consequence
Decreased lighting visibility may result in a vehicle crash.
Corrective Action
Dope, inc. Will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on july 28, 2009. Owners may contact dope, inc. At 1-626-272-1798.
Notes
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under document search located at the bottom of your screen. Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .