9 recalls found. |
DEFECT #1 - SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
Posted on: 2002-09-17
Description
On certain sport utility vehicles equipped with rearward folding head restraints on the second row seats, two potential pinch points exist on each of the folding head restraints when the restraints are folded rearward as the seatback is folded down.
Consequence
If a person were to insert their finger(s) into the pinch point when the head restraint folds, it could trap and pinch the finger(s) causing injury.
Corrective Action
Dealers will install protective covers over the pinch points. Owner notification began november 8, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, gmc at 1-800-462-8782, or cadillac at 1-800-458-8006.
Notes
Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
Posted on: 2002-07-22
Description
On certain pickup and utility trucks, some of these vehicles have an air bag sensing diagnostic module (sdm) which contains an anomaly that could result in the driver and passenger's air bag failing to deploy during certain frontal crashes.
Consequence
In a vehicle crash, front seat occupants may receive more severe injuries.
Corrective Action
Dealers will recalibrate the sdm on the affected vehicles. Owner notification began august 28, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.
Notes
Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - STRUCTURE:BODY
Posted on: 2000-10-27
Description
Vehicle description: light duty pickup trucks and sport utility vehicles. Some of these vehicles have loose or missing rear wheelhouse plugs. Under certain vehicle operating conditions, exhaust gases can flow forward and accumulate in the rear wheelhouse.
Consequence
These gases could flow into the passenger compartment if the plug is missing or loose and could cause possible illness, unconsciousness, or death.
Corrective Action
Dealers will inspect the vehicle for loose or missing wheelhouse plugs and install new plugs if necessary.
Notes
Owner notification began november 16, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 2000-10-30
Description
Vehicle description: light duty pickup trucks and sport utility vehicles. Some of these vehicles have a clearance condition between the front right-hand brake pipe and the body cross sill that could decrease to the point of allowing contact during the life of the vehicle. If contact occurs and the brake pipe becomes damaged, in half of the brake system there can be a loss of brake fluid and pressure. The brake warning lamp will be activated when the brake fluid level reaches the indicator limit.
Consequence
During braking, the pedal will be lower than normal and stopping distances will be longer. If this occurs when stopping distance is limited, a crash could occur.
Corrective Action
Dealers will inspect the front right-hand brake pipe for wear. If there are signs of wear, this section of the brake pipe will be replaced with a new designed brake pipe section. If there are not signs of wear on the brake pipe, the dealer will install a spacer clip to ensure sufficient clearance between the brake pipe and the body cross sill.
Notes
Owner notification began february 5, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #5 - TIRES:TREAD/BELT
Posted on: 2001-01-03
Description
Tire description: wilderness le tires (both black and raised white letter tires) produced during the week of april 24, 2000 (the seventeenth week of 2000) at the cuernavaca, mexico plant with tire serial numbers v672wl11700 (blackwall) and v672wl21700 (raised white letters). These tires were used as original equipment on model year 2000 yukon xl 1500 series vehicles and were also offered as optional equipment on the 2000 chevrolet suburban 1500 series vehicles. Tread separation can occur due to a lack of adhesion to the first steel belt.
Consequence
Tread belt separation may be noticed by irregular wear, noise, or vibration. With continued use, it may lead to complete separation of the tread/belt package from the tire carcass, possibly resulting in a vehicle crash, personal injury, or death.
Corrective Action
On january 2, 2001, firestone made a public announcement of the defect and that replacement tires are immediately available at no cost to the customer. Replacement tires are available at either their local gm or chevrolet dealer or by their local authorized participating firestone retailer. Owner notification began january 1, 2001. Owners should contact firestone at 1-800-465-1904.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #6 - SERVICE BRAKES, HYDRAULIC:ANTILOCK
Posted on: 2005-08-29
Description
Certain pickup trucks and sport utility vehicles may experience unwanted antilock brake system (abs) activation. This condition is more likely to occur in environmentally corrosive areas. This recall will be launched in the salt belt states of connecticut, delaware, illinois, indiana, iowa, maryland, massachusetts, maine, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia only.
Consequence
This can cause increased stopping distances during low-speed brake applications, which could result in a crash.
Corrective Action
Dealers are to remove the wheel speed sensor and thoroughly clean the wheel speed sensor mounting surface on the bearing, apply rust inhibitor to the cleaned surface, grease the mounting surface, reinstall the wheel speed sensor, and check the peak-to-peak output voltage to ensure the wheel speed signal is within specifications. The recall began september 22, 2005. Owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Notes
Gm recall no. 05068. Gm revised the involved vehicles by amending the original 573 report on october 4, 2005. Gm revised the original 573 report on december 16, 2005, to include additional states and vehicle population.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #7 - FUEL SYSTEM, GASOLINE
Posted on: 2006-05-22
Description
Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on document search and then bus applications). The connector on the fuel filter was not manufactured to honeywell's specification. As a result, the o-ring may not seat correctly on the fuel line.
Consequence
This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. In the presence of an ignition source, a fire could occur.
Corrective Action
Honeywell will notify owners and replace the fuel filters free of charge. The recall began on october 18, 2006. Owners may contact fram customer service at 1-800-890-2075 (option 1).
Notes
This recall only pertains to aftermarket fram fuel filters and has no relation to any original equipment installed on the vehicles listed.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #8 - STRUCTURE
Posted on: 2003-03-18
Description
Certain pickup truck, van, and mini van conversions equipped with southern comfort built running boards that contain certain courtesy lights manufactured by american technology components, inc. These units contain a courtesy light or lights that might overheat when the wire harness is exposed to excessive moisture and road salt.
Consequence
This overheating condition can cause the running board to melt or cause a fire.
Corrective Action
Dealers will replace the wiring harness on these running boards. Owner notification began march 7, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southern comfort at 1-800-745-6096.
Notes
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #9 - WHEELS:CAP/COVER/HUB
Posted on: 2007-12-19
Description
Certain federal-mogul replacement wheel hub assemblies with the brand names: national, carquest p/nos. 515020, 515021, 515025, 515053, 515054, 515059, and 515060, shipped between january 23, 2006, and december 20, 2007, sold for light duty and medium duty trucks. The inboard retention nut used to maintain hub bearing assembly can loosen resulting in an abs light indication, noise, and/or wheel separation.
Consequence
Wheel separation can result in a vehicle crash.
Corrective Action
Federal-mogul will notify customers and will replace the hub assembly free of charge. The recall began on february 7, 2008. Owners can contact federal-mogul toll-free at 877-489-6659.
Notes
This recall only pertains to replacement national, carquest wheel hub assemblies and has no relation to any original equipment installed on vehicles manufactured by general motors or ford.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.