3 recalls found. |
DEFECT #1 - ELECTRICAL SYSTEM:BATTERY:CABLES
Posted on: 2002-01-02
Description
On certain trucks equipped with caterpillar 3406e and c-15 engines, interference between the positive battery cable and stud mounting electronic control module (ecm) to the engine exists. Chafing can wear through the battery cable insulation to allow contact between the battery cable and the stud.
Consequence
This contact could provide a short circuit, which may cause a fire.
Corrective Action
Dealers will inspect the vehicles and the battery cables will be replaced and/or re-routed as necessary. Owner notification began april 18, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - SUSPENSION
Posted on: 2001-06-18
Description
Vehicle description: heavy duty trucks equipped with chalmers 1000 and 800 series suspension kits. These suspension kits may have insufficient penetration of the weld attaching the torque rod eye to the torque rod tube.
Consequence
Failure of the weld could result in separation of the eye and tube, causing a lock of axle retention, which could result in loss of vehicle control.
Corrective Action
Dealers will replace all chalmers fixed torque rods on these vehicles. Owner notification began march 14, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - SUSPENSION:FRONT:HUB
Posted on: 2003-03-26
Description
On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.
Consequence
Seizure of the bearings can cause wheel separation or wheel end fire.
Corrective Action
Dealers will replace both front hubs. Owner notification is expected to begin on or before september 20, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.
Notes
Freightliner recall no. Fl-407.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).