9 recalls found. |
DEFECT #1 - SEAT BELTS
Posted on: 2001-04-09
Description
Vehicle description: certain passenger vehicles, equipped with sunvisor located air bag labels, fail to conform to federal motor vehicles safety standard no. 208, occupant crash protection. These vehicles have a message area less than 30 cm which does not meet the requirements of the standard.
Consequence
These vehicles do not comply with the standard.
Corrective Action
Gm will mail a new bilingual air bag label with installation instructions. However, the customer may bring the label to their dealer for installation free of charge. Owner notification began may 4, 2001. Owners who do not receive the free label and installation instructions within a reasonable time should contact oldsmobile at 1-800-442-6537 or buick at 1-800-521-7300.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - SEAT BELTS
Posted on: 2000-08-22
Description
Vehicle description: passenger vehicles, light duty trucks, sport utility vehicles, and mini vans equipped with trw seat belt buckle assemblies. The buckle base of these seat belt assemblies were not properly heat treated and therefore do not pass the load bearing requirement of federal motor vehicle safety standard no. 209, seat belt assemblies.
Consequence
In the event of a vehicle crash, the occupant may not be properly restrained.
Corrective Action
Dealers will inspect the vehicle's safety belt buckle assembly date codes and, if necessary, will replace any safety belt buckle assembly.
Notes
Owner notification began august 24, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact buick at 1-800-521-7300; chevrolet at 1-800-222-1020; gmc at 1-800-462-8782; oldsmobile at 1-800-442-6537; pontiac at 1-800-762-2737; or saturn at 1-800-553-6000. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - AIR BAGS:SIDE/WINDOW
Posted on: 2000-11-16
Description
Vehicle description: passenger vehicles. Some of these vehicles exhibit a condition in which the driver side impact air bag inflator separates from the air bag module during deployment.
Consequence
If the inflator separates, the air bag will not deploy properly during a crash and occupant protection would be reduced. If is also possible that a separated inflator could be propelled downward and could result in injury to a rear seat passenger whose foot is positioned approximately under the inflator module.
Corrective Action
Dealers will replace the side impact air bag module.
Notes
Owner notification is expected to begin during december 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or buick at 1-800-521-7300.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - STEERING
Posted on: 2008-10-20
Description
Dorman products is recalling 3,900 intermediate steering shafts dorman part nos. 425-151, 425-152, and 425-153, (sold under dorman's oe solutions brand name), balkamp #'s 7-3057, 7-3058, 7-3059 (sold under the napa brand name), and platinum parts #'s 2425151, 2425152, and 2425153 manufactured during the month of september 2007. These replacement steering shafts can be used on the vehicles listed above. The weld connecting the inner tube to the outer tube may be defective.
Consequence
If the weld fails, loss of steering could result, possibly resulting in a vehicle crash.
Corrective Action
Dorman will notify owners and replace the steering shafts free of charge. The recall began on october 16, 2008. Owners may contact dorman toll free at 1-800-523-2492.
Notes
This recall only pertains to dorman's oe solutions brand name, balkamp's napa brand, and the platinum brand steering shafts and has no relation to any original equipment installed on vehicles manufactured by general motors corporation.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #5 - ENGINE AND ENGINE COOLING
Posted on: 2009-04-08
Description
General motors is recalling 1,497,516 my 1997-2003 buick regal, my 1998-2003 chevrolet lumina, monte carlo and impala, my 1998-1999 oldsmobile intrigue, my 1997-2003 pontiac grand prix vehicles equipped with a 3.8l v6 naturally aspirated engine. Some of these vehicles have a condition in which drops of engine oil may be deposited on the exhaust manifold through hard braking.
Consequence
If the manifold is hot enough and the oil runs below the heat shield, it may ignite into a small flame and may spread to the plastic spark plug wire channel and beyond increasing the risk of an engine compartment fire.
Corrective Action
Dealers will replace the engine¿s front valve cover and front-valve-cover gasket with new parts of an improved design and remove the engine¿s plastic cover and plastic oil-fill-tube extension, free of charge. The recall is expected to begin during may 2016. Owners may contact chevrolet at 1-800-630-2438, oldsmobile at 1-800-630-6537, and pontiac at 1-800-620-7668 or http://www.pontiac.com or http:www.gmownercenter.com.
Notes
Gm recall no. 09047.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #6 - STEERING
Posted on: 2009-02-17
Description
Dorman is recalling 979 steering knuckles, dorman p/nos. 697-902 and 697-903, sold under dorman's oe solutionstm brand name, and napa p/nos. 7-8502 and 7-8503 which were sold for replacement use on the various vehicles listed above. A potential material or design defect could result in the steering knuckle breaking in the hub area.
Consequence
A broken steering knuckle could result in loss of steering control and a possible crash without warning.
Corrective Action
Dorman will notify owners and replace the defective steering knuckles free of charge and reimburse the repair facility or owner for labor. The recall began on february 23, 2009. Owners may contact dorman's toll-free hotline at 1-800-523-2492 and press 5.
Notes
This recall only pertains to aftermarket dorman steering knuckles and has no relation to any original equipment installed on vehicles manufactured by general motors corporation.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #7 - ENGINE AND ENGINE COOLING
Posted on: 2008-03-12
Description
Gm is recalling 207,542 my 1997-2003 buick regal and pontiac grand prix vehicles equipped with a 3.8l supercharged v-6 engine. These vehicles have higher front rocker cover gasket temperatures, creating the potential for earlier degradation of the front rocker cover gasket and eventual oil seepage.
Consequence
Certain underhood fires may be caused by drops of engine oil, from seepage or spillage, being deposited on the exhaust manifold through hard braking. If the manifold is hot enough and the oil runs below the heat shield, it may ignite into a small flame and, in some instances, the fire may spread to the plastic spark plug wire channel and beyond.
Corrective Action
Dealers will replace the engine¿s front valve cover and front-valve-cover gasket with new parts of an improved design and remove the engine¿s plastic cover and plastic oil-fill-tube extension, along with the 1-3-5 spark plug wire retainers, free of charge. The recall is expected to begin during may 2016. , free of charge. The recall is expected to begin during may 2016. Until the remedy is completed, gm strongly recommends that owners observe the following important precautions (1) that owners do not park their vehicle in a garage, car port, or other structure; (2) if owners notice a burning odor, they should have their dealer inspect the vehicle. The dealer will inspect the vehicle without charge; (3) use premium fuel (91 octane or higher) in the vehicle as recommended in the vehicle's owner manual. Owners may contact buick at 1-866-608-8080 or pontiac at 1-800-620-7668, or through their website at http://www.gmownercenter.com .
Notes
Gm recall no. 07035. Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #8 - ENGINE AND ENGINE COOLING:ENGINE
Posted on: 2015-10-26
Description
General motors llc (gm) is recalling certain model year 1998-1999 chevrolet lumina and oldsmobile intrigue, 1997-2004 buick regal and pontiac grand prix, 2000-2004 chevrolet impala, and 1998-2004 chevrolet monte carlo vehicles. The affected vehicles were previously repaired under recalls 08v-118, 09v-116, and 15v-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence
Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Corrective Action
The remedy applied under recalls 08v-118, 09v-116, and 15v-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine¿s front valve cover and gasket. Vehicles that are covered by recalls 08v-118, 09v-116, or 15v-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on february 19, 2016. Owners may contact chevrolet customer service at 1-800-222-1020, buick customer service at 1-800-521-7300, oldsmobile customer service at 1-800-442-6537 and pontiac customer service at 1-800-458-8006. Gm's number for this recall is 15757. Note: until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #9 - ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Posted on: 2015-10-26
Description
General motors llc (gm) is recalling certain model year 1998-1999 chevrolet lumina and oldsmobile intrigue, 1997-2004 buick regal and pontiac grand prix, 2000-2004 chevrolet impala, and 1998-2004 chevrolet monte carlo vehicles. The affected vehicles were previously repaired under recalls 08v-118, 09v-116, and 15v-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence
Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Corrective Action
The remedy applied under recalls 08v-118, 09v-116, and 15v-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine¿s front valve cover and gasket. Vehicles that are covered by recalls 08v-118, 09v-116, or 15v-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on february 19, 2016. Owners may contact chevrolet customer service at 1-800-222-1020, buick customer service at 1-800-521-7300, oldsmobile customer service at 1-800-442-6537 and pontiac customer service at 1-800-458-8006. Gm's number for this recall is 15757. Note: until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.