5 recalls found. |
DEFECT #1 - SEAT BELTS:FRONT:RETRACTOR
Posted on: 2001-05-22
Description
Vehicle description: pickup and utility trucks. Some of these vehicles have an internal component in the outboard seat belt retractors for the 2nd and 3rd row of seats that could be cracked. With repeated actuation of the locking mechanism, the crack could spread to the point such that the seat belt would no longer lock.
Consequence
In a crash, increased occupant injury could result from the no-lock condition.
Corrective Action
Dealers will inspect the outboard seat belts for specific lot numbers and replace the belts if necessary. Gm is enclosing an inspection procedure for the owners to use or they can have their dealers do the inspections. Owner notification began july 2, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - STRUCTURE:BODY
Posted on: 2000-10-27
Description
Vehicle description: light duty pickup trucks and sport utility vehicles. Some of these vehicles have loose or missing rear wheelhouse plugs. Under certain vehicle operating conditions, exhaust gases can flow forward and accumulate in the rear wheelhouse.
Consequence
These gases could flow into the passenger compartment if the plug is missing or loose and could cause possible illness, unconsciousness, or death.
Corrective Action
Dealers will inspect the vehicle for loose or missing wheelhouse plugs and install new plugs if necessary.
Notes
Owner notification began november 16, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - SERVICE BRAKES, HYDRAULIC:ANTILOCK
Posted on: 2005-08-29
Description
Certain pickup trucks and sport utility vehicles may experience unwanted antilock brake system (abs) activation. This condition is more likely to occur in environmentally corrosive areas. This recall will be launched in the salt belt states of connecticut, delaware, illinois, indiana, iowa, maryland, massachusetts, maine, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia only.
Consequence
This can cause increased stopping distances during low-speed brake applications, which could result in a crash.
Corrective Action
Dealers are to remove the wheel speed sensor and thoroughly clean the wheel speed sensor mounting surface on the bearing, apply rust inhibitor to the cleaned surface, grease the mounting surface, reinstall the wheel speed sensor, and check the peak-to-peak output voltage to ensure the wheel speed signal is within specifications. The recall began september 22, 2005. Owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Notes
Gm recall no. 05068. Gm revised the involved vehicles by amending the original 573 report on october 4, 2005. Gm revised the original 573 report on december 16, 2005, to include additional states and vehicle population.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #4 - FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Posted on: 2005-04-19
Description
Certain trucks and sport utility vehicles were built with fuel module reservoir assemblies that contain fuel pump wires connectors may overheat under certain operating conditions.
Consequence
If the ignition circuit wire is exposed, the fuel pump fuse will blow, disabling the fuel pump and causing an engine stall or no-start condition. If sufficient heat is conducted to the pass-through connector, a hole in the connector may result, which may cause a 'service engine soon' light to be illuminated during the emission system diagnostic routine. Fuel vapor and in some cases liquid fuel may leak out of the fuel tank through the hole in the connector body. Fuel leakage, in the presence of an ignition source, could result in a fire. Also if the ignition circuit or ground wire is exposed and shorts to the fuel level sender card wires, inaccurate fuel level readings may result.
Corrective Action
Dealers will remove the fuel tank, and remove the module reservoir assemblies from the tank, and install a new service kit free of charge. An interim letter to owners was mailed on may 25, 2005. The owners were re-notified on october 19, 2005, since parts are now availabe. Owners may contact chevrolet at 1-800-630-2438 and gmc at 1-866-996-9463.
Notes
Gm recall no. 05027. Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #5 - WHEELS:CAP/COVER/HUB
Posted on: 2007-12-19
Description
Certain federal-mogul replacement wheel hub assemblies with the brand names: national, carquest p/nos. 515020, 515021, 515025, 515053, 515054, 515059, and 515060, shipped between january 23, 2006, and december 20, 2007, sold for light duty and medium duty trucks. The inboard retention nut used to maintain hub bearing assembly can loosen resulting in an abs light indication, noise, and/or wheel separation.
Consequence
Wheel separation can result in a vehicle crash.
Corrective Action
Federal-mogul will notify customers and will replace the hub assembly free of charge. The recall began on february 7, 2008. Owners can contact federal-mogul toll-free at 877-489-6659.
Notes
This recall only pertains to replacement national, carquest wheel hub assemblies and has no relation to any original equipment installed on vehicles manufactured by general motors or ford.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.