6 recalls found. |
DEFECT #1 - VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
Posted on: 2001-08-23
Description
Vehicle description: passenger cars, sport utility vehicles, and light and medium duty pickup trucks. A switch located in the plastic cover of the wiper motor gear case could malfunction and overheat, potentially resulting in loss of intermittent wiper function, loss of wiper park function, complete loss of wiper function, or ignition of the plastic cover material. Switch malfunction is most likely to occur when the intermittent setting of the wipers is being used, or when snow or ice obstructs the blades from returning to the parked position at the bottom of the windshield. These vehicles were built at the following assembly plants: atlanta plant from 2/11/00 through 7/31/00; chicago plant from 2/14/00 through 8/4/00; kansas city plant from 2/26/00 to 9/4/00; kentucky truck plant from 2/18/00 to 8/31/00; michigan truck plant from 2/23/00 through 8/3/00; norfolk plant from 2/21/00 through 7/27/00; wayne stamping and assembly plant from 2/25/00 through 8/15/00; and wixom plant from 2/15/00 through 8/8/00.
Consequence
Loss of visibility while driving increases the risk of a crash.
Corrective Action
Dealers will inspect the date code on the wiper motor. Motors built with the suspect time frame will have the wiper motor gear case cover replaced. Owner notification began august 20, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
Posted on: 2000-12-12
Description
Vehicle description: minivans and passenger vehicles. A restraint control module (rcm) or a side or front crash sensor may have been assembled with one or more of the screws that mount the circuit board in the housing missing. If some or all of the screws are missing, the performance of the occupant restrains could be affected.
Consequence
In some cases, less than the intended level of protection in the event of a crash.
Corrective Action
Dealers will inspect the rcm and crash sensors and, if necessary, replace them.
Notes
Owner notification began december 21, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - TIRES
Posted on: 2000-12-15
Description
Vehicle description: certain limousines stretched over 60 inches fail to comply with the requirements of fmvss no. 109, new pneumatic tires, and no. 110, tire selection and rims.
Consequence
The vehicle weight could exceed the maximum load rating for the tire, increasing the risk of premature tire wear or blowout.
Corrective Action
Dealers will replace all 5 tires (including the spare tire) with michelin tires (225/70r16 107t reinforced white sidewall) with a sufficiently higher load rating. Owner notification began january 10, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-248-0186.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Posted on: 2001-07-17
Description
Vehicle description: passenger and sport utility vehicles, pickup trucks, and minivans. Equipped with seat belts supplied by trw. It is possible that the driver's and/or front passenger's outboard seat belt buckle may not fully latch. Ford crown victoria built at st. Thomas assembly plant from 4/17/00 - 5/29/01 mercury grand marquis built at st. Thomas assembly plant from 4/17/00 - 5/29/01. Lincoln town cars built at wixom assembly plant from 3/27/00 - 5/30/01. Lincoln navigators built at michigan truck plant from 4/11/00 - 5/31/01. Ford windstars built at oakville assembly plant from 3/23/00 - 5/30/01. Ford rangers built at twin cities plant from 3/28/00 - 5/30/01, and also at the edison plant from 3/13/00 - 5/25/01. Ford f-150 truck built at norfolk plant from 4/18/00 - 5/25/00; at ontario plant from 5/10/00 - 5/28/01; at kansas city plant from 9/11/99 - 5/25/01; and at cuautitlan plant from 5/16/00 - 6/9/01. Ford super duty f-250, f-350, f-450, and f-550 trucks built at kentucky plant from 4/17/00 - 5/27/01; and at cuautitlan plant from 5/16/00 - 6/19/01. Ford excursions built at kentucky plant from 4/17/00 - 10/2/00. Ford expeditions built at michigan truck plant from 4/11/00 - 5/31/01.
Consequence
In the event of a crash, the restraint system may not provide adequate occupant protection, increasing the risk of personal injury to the seat occupant.
Corrective Action
Dealers will inspect the front outboard seat belt buckles and if the buckle fails the inspection process, it will be replaced. Owner notification began july 25, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #5 - AIR BAGS
Posted on: 2000-09-14
Description
Certain passenger vehicles, limousines, and mini vans were built with a newly designed restraint control module (rcm). In some cases, the rcm does not recognize certain system faults that could result in an air bag or seat belt pre-tensioner unexpectedly activating during the self-test sequence at vehicle start-up.
Consequence
This condition could result in personal injury.
Corrective Action
Dealers will replace the rcm in these vehicles. Owner notification began september 14, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #6 - STEERING
Posted on: 2015-10-06
Description
Dorman products, inc. (dorman) is recalling certain model dorman steering shafts, part number 425-359, solutions steering shafts, part number 7-0359, and oe solutions steering shafts, part number 425-359, manufactured april 17, 2014, to september 28, 2015. These aftermarket replacement steering shafts are sold for use in 1995-2002 ford crown victoria, mercury grand marquis, and lincoln town car vehicles. These steering shafts may separate during operation if the integral fastener is loose or missing and if the interfacing vehicle shaft is compressed in length.
Consequence
If the shafts separate during vehicle operation, a loss of steering control would result, increasing the risk of a vehicle crash.
Corrective Action
Dorman will notify owners, and dealers will replace the steering shaft, free of charge. The recall began on october 28, 2015. Owners may contact dorman customer service at 1-800-523-2492, option 5.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.