4 recalls found. |
DEFECT #1 - STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
Posted on: 2002-05-22
Description
On certain low floor buses, the power steering hose was incorrectly installed.
Consequence
The hose can leak, creating the risk of an engine fire.
Corrective Action
Dealers will replace the hose. Owner notification began july 1, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact new flyer at 1-204-228-8984.
Notes
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - VEHICLE SPEED CONTROL
Posted on: 2002-05-21
Description
On certain buses equipped with electronic throttle control/accelerator pedals supplied by williams controls industries, the weld attaching the clevis to the plate has insufficient penetration and could allow the clevis to separate from the plate.
Consequence
If the clevis separated from the plate while the vehicle was in use, the vehicle would return to idle, increasing the risk of a crash.
Corrective Action
Williams controls is handling the replacement of this pedal. Owners who do not receive the free remedy within a reasonable time should contact williams control at 1-503-684-8600 or new flyer at 204-982-8181.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - STEERING:LINKAGES:TIE ROD ASSEMBLY
Posted on: 2001-09-04
Description
Vehicle description: transit buses. The clamp nuts for the center link tie rods may have been inadequately tightened.
Consequence
Inadequately tightened clamp nuts could lead to the tie rods separating from the center link possibly resulting in a vehicle crash.
Corrective Action
New flyer will will inspect the tie rod end clamp lock nuts to ensure that the nuts are properly tightened. Any damaged tie rods will be replaced. Owner notification began september 17, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact new flyer at 1-204-982-8181.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - EXTERIOR LIGHTING
Posted on: 2007-02-27
Description
Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 108, lamps reflective devices, and associated equipment. The flashing deceleration lamps were an optional item for some of these buses.
Consequence
The standard requires that the deceleration lamp is a solid light rather than a flashing light.
Corrective Action
Dealers will rewire the electrical system to remove the flashing function or install a new programmable logic controller (plc) which will make the lamps burn steady free of charge. The recall began on march 5, 2007. Owners may contact new flyer at 204-934-4874.
Notes
Customers may contact the national highway traffic safety administration1s vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.