3 recalls found. |
DEFECT #1 - EXTERIOR LIGHTING
Posted on: 2002-06-03
Description
Certain transit buses with an option for deceleration lights do not meet all the requirements of fmvss no. 108, lamps, reflective devices, and associated equipment. The deceleration lights are located on the rear center of the bus, above the rear engine door. They are provided as a means of alerting vehicles traveling behind the bus that it is slowing down and may be preparing to stop. Also, the driver activated, flashing hoodlum lights, is to alert the public/police to a dangerous situation occurring in the bus for which the driver requires assistance. Two of these lights are located on the front of the bus at each end of the destination sign and two at the rear of the bus below the level of the roof marker lights. They flash in an alternating pattern from side to side. The standard requires that these lamps shall be wired to be steady burning.
Consequence
This does not meet the requirements of the standard.
Corrective Action
Dealers will retrofit these buses. Owner notification began september 19, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact novabus at 1-505-347-2011.
Notes
Novabus recall no. 02-002. Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).novabus had petitioned the agency for inconsequentiality and the petition was denied by the agency (5-6-02).
DEFECT #2 - ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO-CHARGER
Posted on: 2007-02-06
Description
On certain transit buses equipped with detroit diesel series 50 engines, the electronic control module (ecm) will need to be reprogrammed to activate the exhaust temperature sensor.
Consequence
Engine malfunction could possibly lead to engine and vehicle damage and potential for a vehicle fire.
Corrective Action
Novabus is working with detroit diesel to reprogram the engines (please see 05e050). The recall began on january 26, 2007. Owners may contact detroit diesel at 1-313-592-3708 or novabus at 1-450-472-6410.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #3 - STEERING:LINKAGES:TIE ROD ASSEMBLY
Posted on: 2005-03-02
Description
On certain transit buses equipped with arvinmeritor urresko tie rod clamps, heat treatment of clamps created a surface hardness that could lead to a fracture of the clamps.
Consequence
In the event of a crack, the clamps could break off affecting toe-in and alignment. The tie rod can come loose resulting in steering loss and a crash could occur without prior warning.
Corrective Action
Arvinmeritor is conducting the owner notification and remedy for this campaign. Owners may contact arvinmeritor at 1-866-668-7221 or novabus at 450-974-3134.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.