5 recalls found. |
DEFECT #1 - VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Posted on: 2002-01-11
Description
On certain coaches and bus shells equipped with electronic throttle control/accelerator pedals supplied by williams controls industries, the weld attaching the clevis to the plate has insufficient penetration and could allow the clevis to separate from the plate.
Consequence
If the clevis separated from the plate while the vehicle was in use, the vehicle would return to idle, increasing the risk of a crash.
Corrective Action
Dealers will replace these pedals. Owner notification began december 20, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact prevost at 1-418-831-5432.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - ELECTRICAL SYSTEM:BATTERY
Posted on: 2001-03-01
Description
Vehicle description: transit buses equipped with vanner 60 series battery equalizers. The equalizer could fail to operate properly and cause malfunction of the battery charging system.
Consequence
Without fusing, the equalizer may melt, burn, or smoke, possibly resulting in a fire or a smoke filled bus, thus necessitating a passenger evacuation of the bus. The failure mode can cause operator distraction, and/or possible personal injury.
Corrective Action
Prevost will notify owners to inspect their buses for certain equalizers by the date code. The affected equalizers will be replaced. Owner notification began november 29, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact prevost at 1-418-831-2046 or vanner at 1-800-227-6937.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - ENGINE AND ENGINE COOLING:COOLING SYSTEM
Posted on: 2000-10-27
Description
Vehicle description: transit coaches. Some coolant heaters may have been provided without a combustion chamber (burner tube). A flame will be noticed exiting the exhaust pipe at the bottom of the unit.
Consequence
Damage to the heater and the vehicle in which it is installed is possible if a coolant heater is missing a combustion chamber.
Corrective Action
Dealers will inspect the coolant heater for a combustion chamber. If a chamber is missing, one will be added.
Notes
Owner notification began october 2, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact prevost at 1-418-883-3391. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - SUSPENSION
Posted on: 2000-11-29
Description
Vehicle description: transit coaches. The reinforcement brackets were not welded on the tag axle.
Consequence
This condition could result in a loss of vehicle control, increasing the risk of a crash.
Corrective Action
Dealers will weld the brackets on the tab axle.
Notes
Owner notification began november 21, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact prevost at 1-418-831-2046.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #5 - STEERING:COLUMN
Posted on: 2003-03-18
Description
On certain motor coaches and motor homes, the steering columns may be missing the lower bolt and nut. A replacement bolt and nut was installed to correct this situation on the production line. If a replacement bolt has been used and not tightened properly, the column may come out of the input shaft when the steering column adjustment mechanism is used.
Consequence
In such a case, a loss of steering would occur.
Corrective Action
Dealers will verify the size of the bolt and nut and replace them if needed. Owner notification began april 4, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact prevost at 1-418-831-5432.
Notes
Prevost recall no. Sr03-06.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).