7 recalls found. |
DEFECT #1 - AIR BAGS:FRONTAL
Posted on: 2001-02-07
Description
Vehicle description: passenger, sport utility vehicles and minivans. The passenger air bag inflator modules were built without the correct amount of generant, which produces the gas that fills the air bag. Some were built with a double load of generant and some were built without generant.
Consequence
In the event of a crash that would trigger a passenger air bag deployment, a double load of generant can cause the inflator module to explode. If the air bag module explodes, metal and plastic debris could cause severe injury to vehicle occupant. A module with no generant would not inflate the air bag, and the occupants could receive more severe injuries.
Corrective Action
Dealers will replace the passenger air bag module. Telephone calls were made to owners on january 29, 2001. Follow up owner mailing began on april 17, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737, or saturn at 1-800-553-6000.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - AIR BAGS:SIDE/WINDOW
Posted on: 2000-08-25
Description
Vehicle description: passenger vehicles equipped with a side impact air bag system. The air bag system has a lower side impact safing sensor threshold than specified. Because of this reduced threshold, there could be an inadvertent deployment of the side head curtain air bag with severe slamming of the door.
Consequence
This could cause injury to an occupant.
Corrective Action
Dealers will replace the inflatable restraint sensing and diagnostic module assembly.
Notes
No vehicles have been sold to customers.
DEFECT #3 - POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Posted on: 2000-10-30
Description
Vehicle description: passenger vehicles equipped with automatic transaxles. Some of these vehicles were assembled with the transaxle shift cable clip missing or improperly seated. Without the clip, the cable can slip out of its bracket and the transaxle lever would not move along with the shift lever. The driver may put the shift lever in park, but the transaxle may be in reverse or neutral.
Consequence
Unexpected movement of the vehicle could cause a crash without prior warning.
Corrective Action
Dealers will inspect the transaxle shift cable retainer clip to verify proper installation and, if necessary, replace the clip and adjust the cable to specifications.
Notes
Owner notification began october 27, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact saturn at 1-800-553-6000, prompt #5. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - AIR BAGS:FRONTAL
Posted on: 2002-12-19
Description
On certain passenger, sport utility vehicles and mini vans, some of these vehicles have a passenger air bag that was manufactured without a check valve pin. An air bag without the check valve pin could produce increased pressure at the onset of the air bag deployment and reduced pressure afterward.
Consequence
This could increase the severity of injury to a person who was not properly restrained and who was close to the passenger air bag at the time of deployment. It could also reduce the ab8ility of the air bag to protect a restrained front seat passenger.
Corrective Action
Dealers will inspect and, if necessary, replace the passenger air bag. Owner notification began december 16, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737, oldsmobile at 1-800-442-6537, or saturn at 1-800-553-6000, prompt #3.
Notes
Gm recall no. 02061. Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #5 - EXTERIOR LIGHTING:BRAKE LIGHTS
Posted on: 2005-06-02
Description
On certain sedans and wagons, the plastic housing in the rear tail lamp assembly can become distorted if the brake lamps remain on for an extended time.
Consequence
This can cause (1) an intermittently inoperative brake/tail lamp bulb or (2) a short circuit that opens a fuse causing inoperative brake lamps (including the center high-mounted stop lamp) or tail lamps. A following driver may not know when the brakes have been applied, and a rear-end crash could occur without prior warning.
Corrective Action
Dealers will install two new tail lamp reinforcing socket adapters and sockets free of charge. The recall began on october 17, 2005. Owners may contact saturn at 1-800-972-8876.
Notes
Gm recall no. 05052.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #6 - ELECTRICAL SYSTEM:IGNITION:MODULE
Posted on: 2003-06-23
Description
On certain passenger vehicles equipped with 2.2l l4 (l61) engines, a failure of the ignition control module may cause deterioration in idle quality, reduction in overall engine power, and the vehicle may be hard to start. Continued operation of the vehicle after such an ignition module failure will result in the service engine soon light flashing, and may lead to secondary failures of the catalytic converter, oxygen sensor, and exhaust resonator.
Consequence
Failure of the resonator will cause increased exhaust noise. Prolonged operation of the vehicle following a resonator failure may lead to a fire.
Corrective Action
Dealers will (1) replace the ignition control module, (2) replace the ignition control module and spark plugs, or (3) replace the ignition control module, spark plugs, and update the powertrain control module calibration. Owner notification began on august 4, 2003. Owners should contact saturn at 1-800-553-6000, prompt 3.
Notes
Gm recall no. 03033/saturn recall no. 03-c-06.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #7 - ENGINE AND ENGINE COOLING
Posted on: 2007-11-07
Description
On certain passenger vehicles equipped with a 2.2l 4-cylinder engine, links in the engine's timing chain can separate.
Consequence
If a timing chain link separates while the engine is running, the engine will stall and will not restart increasing the risk of a crash.
Corrective Action
Dealers will replace the timing chain free of charge. The recall began on january 15, 2008. Owners may contact saturn at 1-800-972-8876.
Notes
Gm recall no. 06074.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.