4 recalls found. |
DEFECT #1 - STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
Posted on: 2002-05-22
Description
On certain low floor buses, the power steering hose was incorrectly installed.
Consequence
The hose can leak, creating the risk of an engine fire.
Corrective Action
Dealers will replace the hose. Owner notification began july 1, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact new flyer at 1-204-228-8984.
Notes
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - EXTERIOR LIGHTING
Posted on: 2007-02-27
Description
Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 108, lamps reflective devices, and associated equipment. The flashing deceleration lamps were an optional item for some of these buses.
Consequence
The standard requires that the deceleration lamp is a solid light rather than a flashing light.
Corrective Action
Dealers will rewire the electrical system to remove the flashing function or install a new programmable logic controller (plc) which will make the lamps burn steady free of charge. The recall began on march 5, 2007. Owners may contact new flyer at 204-934-4874.
Notes
Customers may contact the national highway traffic safety administration1s vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #3 - ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Posted on: 2003-05-21
Description
On certain transit buses equipped with cummins westport b gas plus or c gas plus 6 cylinder engines, the electronic control module calibration may not correctly detect a throttle plate actuator failure that could result in an uncommanded open throttle condition.
Consequence
If this event occurs, the vehicle operator will not have control of the engine speed which could possibly result in a vehicle crash.
Corrective Action
Dealers will replace the electronic control module calibration free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact cummins customer assistance center at 1-800-343-7357 or new flyer at 204-934-4882.
Notes
Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - INTERIOR LIGHTING
Posted on: 2009-09-28
Description
New flyer is recalling certain model year 2002 through 2009 transit buses manufactured between may 2002 and september 2009 equipped with luminator horizon led side destination signs. The connector board can corrode due to an accumulation of moisture under the connector.
Consequence
A short could occur, possibly causing smoke and fire.
Corrective Action
New flyer will notify owners and repair the buses free of charge. The safety recall began on october2, 2009. Owners may contact new flyer customer services at 1-204-934-4876.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .