8 recalls found. |
DEFECT #1 - ELECTRICAL SYSTEM
Posted on: 2007-05-04
Description
On certain motor coaches, the electrical wire preparation for the control of solar roof hatches was not carried out properly. This wiring may contain open energized wire ends located in the harness.
Consequence
If the open wire ends come into contact with parts of the frame, it may be possible for a short circuit to occur and then a subsequent fire.
Corrective Action
Dealers will send out technicians to disconnect the power to the wires and reroute the wires properly free of charge. The recall began on may 18, 2007. Owners may contact setra at 1-800-882-8054.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #2 - ELECTRICAL SYSTEM:WIRING
Posted on: 2007-05-08
Description
On certain motor coaches, the electrical wiring harness located behind the rear toilet was not properly installed. As a result, rubbing can occur on the outside wire insulation causing the insulation to wear away and eventually cause subsequent arcing.
Consequence
This could lead to a short circuit and possibly a subsequent fire.
Corrective Action
Dealers will check the wiring harness routing and will change the damaged wires. In addition the wiring harness will be relocated in such a way as to prevent rubbing. The recall began on may 18, 2007. Owners may contact setra at 1-800-882-8054.
Notes
Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #3 - ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Posted on: 2006-06-29
Description
On certain motor coaches equipped with detroit diesel series c-60 engines, the electronic control module (ecm) will require to be reprogrammed to current mainframe calibrations.
Consequence
Reprogramming the ecm will prevent the potential of a turbocharger failure from progressing to an engine compartment fire.
Corrective Action
Detroit diesel is conducting this recall (please see 06e019000) and will reprogram the ecm to current mainframe calibrations free of charge. Owners may contact detroit diesel at 313-592-3708 or setra at 905-403-7807.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #4 - PARKING BRAKE:INDICATOR LIGHT
Posted on: 2005-05-19
Description
Certain (36-58 passenger) motor coaches fail to comply with the requirements of federal motor vehicle safety standard no. 101, controls and displays. The parking brake indicator lamp illuminates in green and not red, when the parking brake is engaged.
Consequence
Illumination in red is required by the applicable standard.
Corrective Action
Dealers will install appropriate software to change the color of the parking brake indicator lamp from green to red free of charge. The recall began on may 24, 2005. Owners may contact setra at 1-800-882-8054.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #5 - PARKING BRAKE:INDICATOR LIGHT
Posted on: 2005-05-20
Description
On certain 36-58 passenger motor coaches, the parking brake indicator light on the dashboard may illuminate in limited circumstances even though the parking brake is not engaged.
Consequence
The driver may misinterpret the signal and wrongly assume the parking brake is engaged. The vehicle could roll unaware, which could result in a crash without warning.
Corrective Action
Dealers will replace the parking brake pressure switch free of charge. The recall on may 24, 2005. Owners may contract setra at 1-800-882-8054.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #6 - EQUIPMENT:OTHER:LABELS
Posted on: 2009-02-04
Description
Setra is recalling 490 my 1984-2001 s215, my 1994-2002 s217 and my 2003-2009 s417 motor coaches equipped with emergency exits. These motor coaches fail to comply with the requirements of federal motor vehicle safety standard no. 217, bus emergency exits and window retention and release. When a release mechanism is not located within an occupant space of an adjacent seat, a label meeting the requirements of s5.5.2 that indicates the location of the nearest release mechanism shall be placed within the occupant space. Example: emergency exit instructions located next to seat ahead these labels are not installed in the motor coaches mentioned in the example above.
Consequence
In the event of a crash, without the correct instructions a passenger may not know how to unlatch and open the emergency exit increasing the risk of injury.
Corrective Action
Dealers will send labels with a service instructions explaining the location of the labels free of charge. The recall is expected to begin during march 2009. Owners may contact setra at 1-800-882-8054.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #7 - VISIBILITY:GLASS, SIDE/REAR
Posted on: 2011-04-06
Description
Setra is recalling certain model year 2003-2010 s417 and model year 2011 s417 tc motor coaches for failing to comply with the requirements of federal motor vehicle safety standard no. 205, glazing materials. The partition glass behind the driver of each affected bus does not have the necessary dot markings as specified and was not marked correctly.
Consequence
Compliance to fmvss 205 is required for any and all vehicles in the united states to assure minimum safety requirements.
Corrective Action
Dealers will replace the partition glass free of charge. The safety recall is expected begin during may 2011. Owners may contact setra at 1-800-882-8054.
Notes
This recall campaign is an expansion to 10v-625.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #8 - SUSPENSION:FRONT:CONTROL ARM
Posted on: 2016-03-08
Description
Setra of north america (setra) is recalling certain model year 2005-2009 s417 coaches manufactured march 1, 2005, to february 28, 2009, that had service part lower control arm(s) installed. The hot crimping that connects the tube ends to the control arm joint housing shafts may crack, causing the tube to separate from the shaft.
Consequence
Should the tube crack and separate from the shaft of the vehicle, loss of vehicle control is possible, increasing the risk of a crash.
Corrective Action
Mci, the sales agent for these vehicles, notified owners verbally, and dealers will replace the lower control arms, free of charge. The recall began on march 28, 2016. Owners may contact setra customer service at 1-800-241-2947. Setra's number for this recall is 33.10u10124b.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.