Recalls for 2005 Volvo S80

7 recalls found.

All Volvo Recalls

SO04XWU VOLVO S80 2.4 D5 SE

peeler2007 posted a photo:

Was showing 212,775 miles at last MOT 31/12/19. On VCAR, Cat B. Auction entry. No keys supplied. No V5 supplied : Certificate of Destruction required. Repossession. Not my image.

DEFECT #1 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Posted on: 2007-03-29
Description
Certain cardone master cylinders with part numbers 10-2925, 10-2987, 10-2987mza, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, and 11-3156, and with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. The seal on master cylinder can fail and leak brake fluid.

Consequence
Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.

Corrective Action
Cardone will notify owners and offer to repurchase any defective master cylinders. The recall began during april 2007. Owners can contact cardone at 1-800-777-4780.

Notes
This recall only pertains to aftermarket cardone master cylinders and has no relation to any original equipment installed on the vehicles listed above.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

DEFECT #2 - EQUIPMENT:OTHER:LABELS

Posted on: 2006-10-03
Description
Certain vehicles fail to conform to the requirements of federal motor vehicle safety standard no.  110, tire selection and rims.  The label denoting the tire and loading pressure information is incorrect.

Consequence
A misprinted label would lead to improper vehicle loading specifications or tire inflation which could result in a tire failure, increasing the risk of a crash.

Corrective Action
Dealers will mail the correct labels free of charge.  The recall began on december 18, 2006.  Owners may contact volvo at 1-800-458-1552.

Notes
Volvo recall no.  161.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

DEFECT #3 - ELECTRICAL SYSTEM:STARTER ASSEMBLY:SOLENOID

Posted on: 2005-11-17
Description
On certain passenger and sport utility vehicles, due to an error in the factory assembly instruction, the b+terminal may be in conflict with the starter motor solenoid.  If this occurs, the conflict between the b+terminal and the starter motor solenoid may develop into a short circuit of the battery cable to ground.

Consequence
Smoke may appear from under the hood and it may be impossible to start the car.  If the short circuit happens during driving, electrical power could be lost resulting in the warning lamps being deactivated.  An electrical short could result in a fire.

Corrective Action
Dealers will inspect and increase distance between the b+terminal and the starter motor solenoid by adjusting the terminal.  The recall began on january 31, 2006.  Owners may contact volvo at 1-800-458-1552.

Notes
Volvo recall no.  R150.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

DEFECT #4 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Posted on: 2010-11-16
Description
Volvo is recalling certain vehicles equipped with garmin 760 portable global positioning system (gps) units because the batteries on those units may overheat.

Consequence
An overheated battery could lead to a fire.

Corrective Action
Volvo advises owners to please stop using the garmin portable gps device immediately, and visit the garmin website to determine if their unit is affected.  The unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb.  This service will be performed free of charge.  The safety recall began on november 18, 2010.  Owners may contact garmin at 866-957-1981 or visit garmin's website at www.garmin.com/nuvibatterypcbrecall.

Notes
Volvo safety recall no.  R231.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .

DEFECT #5 - FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Posted on: 2009-12-18
Description
Volvo is recalling certain model year 2001-2005 s80, model year 2001-2004 v70, s60, xc70 and model year 2003-2005 xc90 vehicles sold in or registered in the states of alabama, arizona, arkansas, california, florida, georgia, hawaii, kentucky, louisiana, mississippi, nevada, new mexico, north carolina, oklahoma, south carolina, tennessee, texas, utah, virginia and the u.s.  Territories.  When exposed to certain environmental conditions (hot climate and temperature cycling) over time and in combination with varying fuel quality, the fuel pump can develop cracks in the fuel pump flange.

Consequence
If the condition occurs vehicle owners may notice fuel smell and/or fuel leak which, in the presence of an ignition source, could result in a fire.

Corrective Action
Dealers will inspect the fuel pump installed in the vehicle, and if necessary replace the fuel pump with a part of a modified design.  This service will be performed free of charge.  The safety recall began on january 15, 2010.  Owners may contact volvo at 1-800-458-1552.

Notes
Volvo safety recall no.  R220.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .

DEFECT #6 - AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Posted on: 2021-10-01
Description
Volvo car usa, llc (volvo car) is recalling certain 2001-2006 s80 and 2001-2009 s60 vehicles.  The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence
An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Corrective Action
Dealers will replace the driver's air bag, free of charge.  Owner notification letters were mailed november 29, 2021.  Owners may contact volvo car customer service at 1-888-458-1552.  Volvo's number for this recall is r10125.

Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.nhtsa.gov.