|
|
Recalls for
2005 Volvo Xc90
|
6 recalls found.
|
DEFECT #1 - ELECTRICAL SYSTEM:BATTERY:CABLES
Posted on: 2007-05-25
Description
On certain passenger vehicles, it has been determined that while doing battery maintenance the jack's crank handle can be misplaced under a bracket which retains the battery.
Consequence
Misplacement of the jack's crank handle can pose a safety risk as it can result in a short circuit of the battery which could then lead to a fire.
Corrective Action
Dealers will inspect and ensure proper placement of the jack crank handle and a warning label with approved text will be affixed to the bracket which retains the battery. This warning label will inform an operator not to place the jack crank handle between the bracket and the battery free of charge. The recall began on july 7, 2007. Owners may contact volvo at 1-800-458-1552.
Notes
Volvo recall no. Sc179.this action is deemed a safety improvement campaign and is not being conducted under the safety act.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. DEFECT #2 - STEERING:LINKAGES:TIE ROD ASSEMBLY
Posted on: 2006-05-09
Description
On certain passenger vehicles,the outer tie rod ball joint can deform at high loads causing a loss of the clamping force and the nut may loosen, which may eventually lead to a fatigue fracture of the outer tie rod ball joint.
Consequence
The driver may notice that the vehicle is difficult to maneuver increasing the risk of a crash.
Corrective Action
Dealers will replace the outer ball joint tie rods with improved outer ball joint tie rods free of charge. The recall began on june 23, 2006. Owners may contact volvo at 1-800-458-1552.
Notes
Volvo recall no. R157.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. DEFECT #3 - VISIBILITY:WINDSHIELD WIPER/WASHER
Posted on: 2006-04-28
Description
On certain vehicles, if the wiper arm is activated in extreme winter weather conditions and without lifting the wiper arms and cleaning the windshield prior to moving, the wiper arm might slip on its driveshaft, resulting in an inability to move the wipers from the park position.
Consequence
Inoperative wipers under inclement weather conditions could cause a crash due to impaired visibility.
Corrective Action
Dealers will replace the wiper arms and retaining nuts. The recall began on september 5, 2006. Owners may contact volvo cars at 1-800-458-1552.
Notes
Volvo recall no. R156.customers may also contact the national highway traffic safety administrationvolvo recall no. R156.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. DEFECT #4 - ELECTRICAL SYSTEM:STARTER ASSEMBLY:SOLENOID
Posted on: 2005-11-17
Description
On certain passenger and sport utility vehicles, due to an error in the factory assembly instruction, the b+terminal may be in conflict with the starter motor solenoid. If this occurs, the conflict between the b+terminal and the starter motor solenoid may develop into a short circuit of the battery cable to ground.
Consequence
Smoke may appear from under the hood and it may be impossible to start the car. If the short circuit happens during driving, electrical power could be lost resulting in the warning lamps being deactivated. An electrical short could result in a fire.
Corrective Action
Dealers will inspect and increase distance between the b+terminal and the starter motor solenoid by adjusting the terminal. The recall began on january 31, 2006. Owners may contact volvo at 1-800-458-1552.
Notes
Volvo recall no. R150.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. DEFECT #5 - EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
Posted on: 2010-11-16DescriptionVolvo is recalling certain vehicles equipped with garmin 760 portable global positioning system (gps) units because the batteries on those units may overheat.
ConsequenceAn overheated battery could lead to a fire.
Corrective ActionVolvo advises owners to please stop using the garmin portable gps device immediately, and visit the garmin website to determine if their unit is affected. The unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. This service will be performed free of charge. The safety recall began on november 18, 2010. Owners may contact garmin at 866-957-1981 or visit garmin's website at www.garmin.com/nuvibatterypcbrecall.
NotesVolvo safety recall no. R231.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to
http://www.safercar.gov .
DEFECT #6 - FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Posted on: 2009-12-18DescriptionVolvo is recalling certain model year 2001-2005 s80, model year 2001-2004 v70, s60, xc70 and model year 2003-2005 xc90 vehicles sold in or registered in the states of alabama, arizona, arkansas, california, florida, georgia, hawaii, kentucky, louisiana, mississippi, nevada, new mexico, north carolina, oklahoma, south carolina, tennessee, texas, utah, virginia and the u.s. Territories. When exposed to certain environmental conditions (hot climate and temperature cycling) over time and in combination with varying fuel quality, the fuel pump can develop cracks in the fuel pump flange.
ConsequenceIf the condition occurs vehicle owners may notice fuel smell and/or fuel leak which, in the presence of an ignition source, could result in a fire.
Corrective ActionDealers will inspect the fuel pump installed in the vehicle, and if necessary replace the fuel pump with a part of a modified design. This service will be performed free of charge. The safety recall began on january 15, 2010. Owners may contact volvo at 1-800-458-1552.
NotesVolvo safety recall no. R220.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to
http://www.safercar.gov .