5 recalls found. |
DEFECT #1 - ENGINE AND ENGINE COOLING
Posted on: 2008-07-30
Description
Navistar is recalling 24,975 my 2003 through 2008 ic be, ce, hc, and re school and commercial buses and 2002 through 2008 international 3200 and 3300 model buses manufactured between september 21, 2001 through december 14, 2007, equipped with international vt365 engines. These vehicles may exhibit engine hard start, no start, or stall conditions due to possibly damaged terminals in the fuse holder connector of the injector drive module (idm) clean battery power circuits. The terminals may have been damaged during electrical continuity testing in the manufacturing process.
Consequence
These conditions could result in a vehicle crash, possibly resulting in personal injury.
Corrective Action
Navistar will notify owners and replace the idm fuse holder free of charge. The recall began on october 3, 2008. Owners can contact navistar toll-free at 1-800-448-7825.
Notes
Navistar's recall no. 08506.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #2 - VEHICLE SPEED CONTROL
Posted on: 2010-06-16
Description
Navistar is recalling certain model year 2003 through 2010 international trucks and ic commercial buses manufactured from december 4, 2001 through december 14, 2009 equipped with international vt365 engines having engine calibration pan2pvr0, pan2pvr1, or pan2pwr. The engine normally responds to a failed open accelerator position sensor circuit fault by returning the engine to low idle speed of 800 rpm and disabling the driver's ability to increase the engine speed. However if the open circuit corrects itself within 30 seconds of initiation, engine speed could suddenly increase to a high idle speed of 1200 rpm.
Consequence
This increase to high idle speed may occur without warning causing a sudden and unexpected shift in vehicle position possibly resulting in property damage, personal injury, or death.
Corrective Action
Navistar will notify owners and dealers will repair the vehicles free of charge. The safety recall began on july 1, 2010. Owners may contact navistar at 1-800-448-7825.
Notes
Navistar's campaign number is 10512.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #3 - SERVICE BRAKES, HYDRAULIC
Posted on: 2010-03-16
Description
Navistar has notified nhtsa about a defect in certain model year 2010 and 2011 ic ce, hc, and be commercial buses and international 1300, 3200, 3300, 4100, 4200, 4300, 4400, and mxt trucks manufactured from november 19, 2003 through february 9, 2010. The parking brake may release if the brake system electronic control unit (ecu) software misinterprets input signals generated from cycling the ignition switch more than once at a specific frequency.
Consequence
Release of the parking brake may cause sudden, unexpected shift in vehicle position possibly resulting in property damage, personal damage, or death.
Corrective Action
Navistar will notify owners and will repair the vehicles by reprogramming the vehicle's brake system ecu free of charge. The safety recall began on april 14, 2010. Owners may contact navistar at 1-260-461-1890.
Notes
Navistar's campaign number is 10505.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #4 - ENGINE AND ENGINE COOLING
Posted on: 2008-02-27
Description
International is recalling 34,993 my 2006-2008 school and transit buses and heavy duty trucks/tractors manufactured between june 1, 2006 and june 28, 2007, equipped with international dt466 or dt570 engines. The base plate of the engine oil cooler may crack allowing pressurized oil to leak into the engine compartment.
Consequence
This condition may cause either engine shut down without warning, or in extreme cases, possible engine fire which can lead to property damage, personal injury, or death.
Corrective Action
International will notify owners and repair the vehicles free of charge. The recall began on november 21, 2008. Owners may contact international at 800-448-7825.
Notes
International recall no. 08502.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #5 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 2012-01-19
Description
Navistar is recalling certain model year 2005-2011 international 3200im, and model year 2007-2011, ic bus model hc buses, manufactured from august 16, 2004, through may 13, 2010. When the bus kneeling feature is activated, the rear brake line may be pinched by a frame member causing the rear brakes to drag.
Consequence
Brakes that drag could overheat and may lead to a fire, which may cause property damage, personal injury, or death.
Corrective Action
Navistar will notify owners, and dealers will install a clip to ensure that the brake line cannot be pinched. This service will be performed free of charge. The safety recall began on april 27, 2012. Owners may contact navistar at 1-800-448-7825.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .