21 recalls found. |
DEFECT #1 - TRAILER HITCHES
Posted on: 2007-06-26
Description
On certain trucks, the removable tow hitch ,when used to tow or lift a vehicle, can fail due to defective material in the tow hitch.
Consequence
If the tow hitch assembly fails while a vehicle is being towed or lifted, it may cause an accident that could result in personal injury or death.
Corrective Action
Dealers will replace the tow pin assembly free of charge. The recall began on september 4, 2007. Owners may contact kenworth at 425-828-5440 or peterbilt at 940-591-4201.
Notes
Peterbilt recall no.507e and kenworth recall no. 07kwa.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #2 - FUEL SYSTEM, GASOLINE:DELIVERY
Posted on: 2007-04-10
Description
On certain trucks, if the ignition switch is turned on prior to initial start up in the manufacturing plant or during the filter replacement in the field, a small flame will ignite when the fuel is added to prime the system.
Consequence
The possibility exists for the flame to spread resulting in possible equipment damage or physical injury.
Corrective Action
Dealers will inspect the filter for the date codes of the suspect filters and replace those heating elements free of charge. The recall began on march 21, 2007. Owners may contact kenworth at 425-828-5440 and peterbilt at 940-591-4201.
Notes
Kenworth recall no. 07kw5 & peterbilt recall no. 307d.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #3 - SERVICE BRAKES, AIR
Posted on: 2007-03-02
Description
Certain trucks fail to comply with the requirements of federal motor vehicle safety standard no. 121, air brake systems. The trailer light line may have been routed using too tight of a bend radius. This routing method could cause the wires within the harness plug to be pulled away from the chassis plug resulting in an intermittent or complete electrical power loss to the trailer.
Consequence
Should power be lost, the electrical circuits would not provide power to the antilock system on the towed vehicle increasing the risk of a crash.
Corrective Action
Dealers will reroute the light line to eliminate the excessive bend radius and replace any plug or harness that has been damaged free of charge. The recall began on april 16, 2007. Owner may contact kenworth at 425-828-5440.
Notes
Paccar recall no. 07kw1.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #4 - POWER TRAIN:AUTOMATIC TRANSMISSION
Posted on: 2007-03-16
Description
On certain trucks, the wiring, parts, or transmission programming required for the auto neutral feature to function as designed were either not installed, connected, or programmed properly.
Consequence
If any of these conditions exists, the transmission will not automatically shift into neutral when left in drive with the parking brake set engaged. The vehicle could move without warning increasing the risk of a crash.
Corrective Action
Dealers will inspect the affected vehicles to ensure the auto neutral feature functions properly and, if needed, will make the necessary repairs free of charge. The recall began on may 9, 2007. Owners may contact kenworth at 425-828-5440.
Notes
Kenworth recall no. 07kw3.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #5 - VEHICLE SPEED CONTROL:CRUISE CONTROL
Posted on: 2006-11-27
Description
An incorrect switch was installed in the cruise control system on certain model t300 trucks.
Consequence
A light application of the brakes will not deactivate the cruise control and the system will have to be shut off by the dash switch. This could lead to unintended acceleration and a crash without warning.
Corrective Action
Kenworth will install the correct sensor switch. The recall began on january 10, 2007. Owners may contact kenworth at 1-425-828-5440.
Notes
Kenworth recall no. 06kw4.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #6 - STEERING:COLUMN
Posted on: 2006-11-27
Description
On certain trucks equipped with a trw tilt/telescoping steering column, the tilt locking mechanism on the steering column may disengage. This could prevent the steering column from locking in to predetermined positions.
Consequence
Should the locking mechanism disengage, the tilting travel of the column would be unrestricted. This unrestricted travel allows the steering wheel to impact the dash and could limit the movement of the steering wheel potentially resulting in difficulty maneuvering the vehicle, increasing the risk of a crash.
Corrective Action
Dealers will replace the tilt locking mechanism with a revised design that incorporates a new bracket for restraining the tilting mechanism. The recall began on december 22, 2006. Owners may contact kenworth at 1-425-828-5440.
Notes
Kenworth recall no. 06kw2.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #7 - SERVICE BRAKES, AIR
Posted on: 2007-03-09
Description
Certain trucks fail to comply with the brake timing regulatory requirements of federal motor vehicle safety standard no. 121, air brake systems. The brake valve was moved to the opposite rail, increasing the length of the air line, which in turn increased the wheelbase requiring a dual relay valve system. The vehicles were manufactured with a single valve system.
Consequence
If stopping distance was limited, a vehicle crash could result.
Corrective Action
Dealers will convert the single relay valve to a dual relay valve system free of charge. The recall began on may 21, 2007. Owners may contact kenworth at 425-828-5440.
Notes
Kenworth recall no. 07kw2.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #8 - POWER TRAIN:AXLE ASSEMBLY
Posted on: 2007-03-22
Description
On certain trucks, the axle housings may have been manufactured with steel that was out of specification which could result in a fatigue failure over time.
Consequence
If a fatigue failure occurs and is left unattended, the axle may lock up or the end of the axle could come off, which may result in a vehicle crash.
Corrective Action
Dealers will inspect and replace the axles free of charge. The recall began on may 9, 2007. Owners may contact kenworth at 425-828-5440 and peterbilt at 1-940-591-4196.
Notes
Kenworth recall no. 07kw4 & peterbilt recall no. 107c.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #9 - SERVICE BRAKES, AIR:SLACK ADJUSTERS
Posted on: 2008-03-04
Description
Paccar is recalling 130 my 2005-2007 kenworth c500, t800, w900, and peterbilt models 357 and 379 tractor trailers equipped with fabco slack adjusters on sisu axles. The slack adjusters may fail as a result of a fatigue crack rendering the slack adjuster inoperative. This could reduce braking effectiveness.
Consequence
Reduction in braking capacity could increase the risk of a crash.
Corrective Action
Dealers will inspect and replace the slack adjusters free of charge. The recall began on march 21, 2008. Owners may contact kenworth at 1-425-828-5440 and peterbilt at 1-940-591-4196.
Notes
Kenworth recall no. 08kw2 and peterbilt recall no. 208c.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #10 - TRAILER HITCHES
Posted on: 2008-03-10
Description
Paccar is recalling 318 my 2007-2009 kenworth t800, w900, and peterbilt 357, 365, 367, 378, 379, 384, 385, 386,388, and 389 trucks equipped with premier trailer hitch assemblies. The pintle hitch assemblies may have been manufactured in a manner resulting in a reduction of fatigue strength of the pivot pins.
Consequence
This reduction of fatigue strength could cause the pivot pin to crack and eventually break, causing the trailer to detach from the truck while in motion, which could cause a crash that could result in personal injury or death.
Corrective Action
Dealers will replace the potentially defective pivot pin free of charge. The recall began on april 18, 2008. Owners may contact kenworth at 1-425-828-5440 or peterbilt at 1-940-591-4196.
Notes
Kenworth recall no. 08kw4 and peterbilt recall no.208d.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #11 - TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
Posted on: 2008-04-18
Description
Paccar is recalling 172 my 2007 kenworth t800 short hood, w900 long hood and t600 tractor/trailers equipped with saf-holland simplex fifth wheels. If the pivot bolt joint for the lever bar is over torqued, the spacer deforms, and makes contact with the lever bar. This condition coupled with corrosion associated with the seasonal dry out, can affect the lock system of the fifth wheel, preventing the fifth wheel jaw from latching securely around the trailer king pin.
Consequence
The fifth wheel may fail to latch without the operator's knowledge, causing the tractor and trailer to disengage increasing the risk of a crash.
Corrective Action
Kenworth is working with saf-holland simplex and will inspect the pivot bolt joint for a deformed spacer and replace the bolt, washer and spacer with a hex-head shoulder bolt and washer free of charge. The recall began on may 1, 2008. Owners may contact kenworth at 1-425-828-5440 or saf-holland at 1-231-773-3271.
Notes
Paccar/kenworth recall no. 08kw5.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #12 - SUSPENSION
Posted on: 2008-09-24
Description
Paccar is recalling 130 my 2004-2009 t2000, t800, t600, w900 and t660 kenworth trucks built with an ag400 rear suspension, long stroke brake chambers, and wide base tires (super singles). These vehicles may develop an increase in lateral and vertical axle movement. This movement may cause part or parts of the brake assembly (brake cam tube support, brake chamber bracket, brake chamber, brake spider) to develop fatigue cracks, possibly resulting in the failure of the part or parts within the brake assembly.
Consequence
A failure may reduce vehicle brake performance, increasing the risk of a crash.
Corrective Action
Dealers will install the cam tube support brackets on all of the rear axle wheel ends. Inspect the rear axle brake assembly and replace it if cracked. The recall is expected to begin during november 2008. Owners may contact kenworth at 1-425-828-5440.
Notes
Kenworth recall no. 08kwb. Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #13 - TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
Posted on: 2008-04-25
Description
Paccar is recalling 3,573 my 2007 kenworth c500, t800, t600, t2000, and w900 chassis built with phillips qcs ii trailer cable connection and trailer cable mounting bracket with 'u-shaped' cut out. Certain trailer cable mounting brackets have a 'u-shaped' cut out that only partially supports the trailer cable connection. Partial support of the cable connection may allow the molded boot and electrical ground pin to partially or completely pull away from the 7-way socket. Partial or complete detachment of the cable connection can cause reduced water resistance and potential loss of electrical ground. There is also a possibility the trailer lights may fail to illuminate without the operator's knowledge.
Consequence
If this condition were to occur, other motorists may not be warned of the tractor/trailer movements, increasing the risk of a crash.
Corrective Action
Dealers will install a reinforcement bracket between the flexible back of the qcs ii molded boot and the frame bracket, and reattach the supporting bolts. The recall began on may may 30, 2008. Owners may contact kenworth at 1-425-828-5440.
Notes
Kenworth recall no. 08kw6.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #14 - ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Posted on: 2008-09-25
Description
Paccar is recalling 4,883 my 2006-2009 kenworth t600, t660, t800, w900, t2000 and my 2008-2009 peterbilt 365, 367, 379, 384, 386, 387, 388 and 389 trucks. Inadequate stiffness of the diesel particulate filter (dpf) bracket could result in separation of the dpf from the chassis.
Consequence
A vehicle crash could occur if another vehicle strikes the dpf on the roadway.
Corrective Action
Paccar is working with caterpillar to repair these vehicles (please see 08e041). Owners may contact caterpillar at 1-800-447-4986 or kenworth at 1-425-828-5440 or peterbilt at 1-940-591-4196.
Notes
Kenworth recall no. 08kwd and peterbilt recall no. 908g.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #15 - FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY
Posted on: 2011-02-25
Description
Paccar is recalling certain model year 2008-2012 kenworth t2000, t660, t700, t800, and w900, as well as model year 2009-2012 peterbilt 365, 367, 384, 386, 387, 388, 389, and 587 trucks equipped with paccar mx engines. The oil module centrifugal spinner filter cap in the paccar mx engine may become loose, possibly allowing the cap to come off and engine oil to partially discharge from the oil module onto exhaust components.
Consequence
The discharge of engine oil onto exhaust components which are hot, such as when the engine is under significant load, may cause a fire.
Corrective Action
Dealers will re-torque the oil module filter cap and install a secondary retention device on the secondary centrifugal spinner filter cap. This service will be performed free of charge. The safety recall is expected to begin during march 2011. Owners may contact kenworth at 1-425-828-5440 and peterbilt at 1-940-591-4196.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #16 - TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
Posted on: 2008-04-25
Description
Paccar is recalling 292 aftermarket saf holland fifth wheels sold for use on my 2007 kenworth t800 short hood, w900 long hood and t600 tractor/trailers. If the pivot bolt joint for the lever bar is over torqued, the spacer deforms, and makes contact with the lever bar. This condition coupled with corrosion associated with the seasonal dry out, can affect the lock system of the fifth wheel, preventing the fifth wheel jaw from latching securely around the trailer king pin.
Consequence
The fifth wheel may fail to latch without the operator's knowledge, causing the tractor and trailer to disengage increasing the risk of a crash.
Corrective Action
Paccar is working with saf-holland and will inspect the pivot bolt joint for a deformed spacer and replace the bolt, washer and spacer with a hex-head shoulder bolt and washer free of charge. The manufacturer has not yet provided an owner notification schecdule. Owners may contact paccar at 1-415-828-5000 or saf-holland at 1-231-773-3271.
Notes
Paccar recall no. 08kw7.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #17 - SERVICE BRAKES, AIR
Posted on: 2009-06-29
Description
Kenworth is recalling 3,423 my 2004-2009 t2000, t800,t600, w900 and t660 vehicles. Increased brake excitation in a certain vehicle configuration which includes bendix drum brakes, wide base low profile single tires, and an ag400 or ag460 rear suspension, due to its unique brake clocking and cam tube length, can cause fatigue and cracking to brake assembly components.
Consequence
Cracking can cause a complete fracture of the cam tube, which could increase stopping distance and decrease parking brake hold capability.
Corrective Action
Dealers will inspect the rear axle brakes assembly, replace cracked rear axle brakes assembly components where required, and install cam tube support brackets on all rear axle wheel ends free of charge. The recall is expected to begin or before july 25, 2009. Owner may contact kenworth at 1-425-828-5440.
Notes
Paccar recall no. 09kw7.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #18 - POWER TRAIN:AXLE ASSEMBLY
Posted on: 2010-12-21
Description
Paccar is recalling certain model year 2007-2008 kenworth and peterbilt vehicles manufactured from february 2, 2006 through april 30, 2007. The bearing surfaces of the extended lube universal joint that attaches the inter-axle driveline to the drive axle may become prematurely worn due to breakdown of lubrication and/or excessive heat. Prematurely worn bearing surfaces may result in the u-joint becoming loose and/or binding. This condition may result in universal joint failure, allowing the inter-axle driveline to detach from the axle.
Consequence
Detachment of the driveline from the axle may cause the vehicle to lose power and become disabled in the roadway. Also, the driveline could drop from the vehicle into the roadway increasing the risk of a crash.
Corrective Action
Paccar is working with its supplier to remedy the vehicles free of charge. The safety recall is expected to begin during february 2011. Owners may contact kenworth at 425-828-5440 and peterbilt at 940-591-4196.
Notes
Kenworth recall no. 10kwl & peterbilt recall no. 1201f.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #19 - SERVICE BRAKES, AIR:DISC
Posted on: 2009-05-19
Description
Paccar is recalling 140 my 2005, 2007-2009 t800, w900, and t660 trucks. The caliper mounting fasteners attaching the air disc brake caliper assembly to the torque plate may have received insufficient torque during the installation process. The insufficient torque may allow the air disc brake caliper assembly to become loose and possibly separate from the vehicle.
Consequence
This could result in reduced braking capacity and also a road debris hazard, increasing the risk of a crash.
Corrective Action
Dealers will inspect air disc brake caliper assemblies and replace the caliper mounting fasteners and torque properly. This service will be performed free of charge. The manufacturer has not yet provided an owner notification schedule. Owners may contact kenworth at 1-425-828-5440.
Notes
Kenworth recall no. 09kw3.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #20 - ENGINE AND ENGINE COOLING
Posted on: 2007-06-28
Description
On certain trucks equipped with caterpillar c11, c13 or c15 engines, the oil fill cap can become dislodged due to cap damage or improper installation and become lodged in the u-joint of the steering driveline and steering gear.
Consequence
If the cap becomes dodged in this area, it may result in difficulty steering the vehicle or cause complete steering lock-up increasing the risk of a crash.
Corrective Action
Paccar is working with caterpillar to repair these vehicles. Revised oil cap retention based on the engine model/configuration will be incorporated to prevent steering lock-up. The recall began during december 2007. Owners may contact caterpillar at 1-800-447-4986 or kenworth at 425-828-5440.
Notes
Kenworth recall no. 07kwb.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #21 - SERVICE BRAKES
Posted on: 2013-11-21
Description
Paccar is recalling certain model year 2007-2014 kenworth t800 and w900 trucks manufactured march 22, 2006, through july 15, 2013 and equipped with primaax tridem rear suspensions and a pusher and/or tag axle. The affected trucks have brake chambers that take longer to apply or release the brakes than the required time limit. Thus, these vehicles fail to conform to the requirements of federal motor vehicle safety standard (fmvss) no. 121, air brake systems.
Consequence
Brakes that take longer to apply may lengthen the distance needed to stop the truck, increasing the risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will modify the air brake system, free of charge. The recall began on january 15, 2014. Owners may contact paccar at 1-425-468-7400. Kenworth's recall number is 13kwl.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.