4 recalls found. |
DEFECT #1 - ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS
Posted on: 2006-03-31
Description
On certain motor homes, the bussman box was incorrectly soldered and could fail.
Consequence
Electrical power may be lost to components of the major chassis operating systems (engine, transmission, starting, cooling) causing the vehicle to shutdown and/or not be capable of powering up. One or a combination of the following conditions may occur: loss of electrical power to the engine, transmission starting and engine cooling systems, in the operation of the right chassis stop/turn signal and right trailer stop/turn signal, antilock brake system (abs), auxiliary brake system, heater elements in the air dryer, and/or the heater element in the water in-fuel separator, increasing the risk of a crash.
Corrective Action
Dealers will replace the defective components. The recall began on april 10, 2006. Owners may contact spartan at 1-517-543-6400.
Notes
Spartan recall no. Spec 06005.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #2 - STEERING
Posted on: 2013-05-08
Description
Spartan motors chassis (spartan) is recalling certain model year 2006-2011 k2, and k3 and 2006-2010 mm motorhome chassis manufactured july 20, 2005, through december 17, 2010. The steering gear mounting brackets may crack and detach resulting in a loss of steering.
Consequence
A loss of steering control may increase the risk of a crash.
Corrective Action
Spartan will notify owners. Starting in mid-june 2013, dealers will install a replacement bracket or a reinforcement to the existing bracket. Until the remedy is available, owners may have their vehicle inspected at any spartan service center. All repairs will be performed free of charge. Notices were mailed to owners on june 24, 2013. Owners can contact spartan at 1-855-589-9836.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #3 - ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Posted on: 2016-05-17
Description
Spartan motors (spartan) is recalling certain model year 2007-2015 spartan k3 and mm motorhome chassis manufactured september 21, 2006, to march 23, 2015. In the affected vehicles, the flexible exhaust tube may tear allowing hot exhaust to blow against other components or materials.
Consequence
If hot exhaust gas contacts other components or materials, it can increase the risk of a fire.
Corrective Action
Spartan will notify the motorhome manufacturers that purchased the affected chassis, and spartan dealers will inspect the alignment of the tubes, correcting them and replacing any that are torn. These repairs will be performed free of charge. The recall began on june 23, 2016. Owners may contact spartan customer service at 1-517-543-6400. Spartan's number for this recall is 16014.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #4 - ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
Posted on: 2015-09-01
Description
Spartan motors usa (spartan) is recalling certain model year 2004-2008 k2, k3 and mm motorhomes manufactured march 17, 2003, to march 15, 2007. In the affected vehicles, the engine cooling fan may separate from the fan drive while the fan is spinning.
Consequence
If the engine area is open and the cooling fan is operating and detaches, someone nearby may be injured.
Corrective Action
Spartan will notify owners, and dealers will replace the fan and fan drive system, free of charge. Interim notices were mailed to owners on october 29, 2015. The recall began on october 29, 2015. Owners may contact spartan customer service at 1-800-582-3454. Spartan's number for this recall is 15014.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.