36 recalls found. |
DEFECT #1 - VISIBILITY:WINDSHIELD WIPER/WASHER:SWITCH/WIRING
Posted on: 2007-01-29
Description
Certain 2007 and 2008 my blue bird vision school buses manufactured between october 16, 2006, and january 18, 2007. Continuous resetting of the circuit breaker when the wiper/washer is operating in the wash/wipe mode may cause failure in the wiring circuit resulting in power being applied to the ground which could cause the circuit breaker to overheat and fail resulting in a stalled wiper.
Consequence
Failure of the wiper in inclement weather conditions may cause a vehicle crash, possibly resulting in property damage, personal injury or death.
Corrective Action
Blue bird will notify owners and repair the buses free of charge. The recall is expected to begin on february 28, 2007. Owners can contact blue bird at 478-822-2242.
Notes
Blue bird recall no. R07lh.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #2 - STEERING:COLUMN
Posted on: 2006-12-06
Description
Certain 2008 blue bird vision school buses built from october 23 through november 21, 2006. A temporary bolt was used to secure the steering wheel during the manufacturing process. The temporary bolt was to be removed and replaced with a permanent bolt with a lock coating during the final assembly stage. The temporary bolt was not removed and replaced on the subject units, but instead the bolt was reused.
Consequence
Reuse of the attaching screw could allow the steering wheel to loosen during operation which could result in a vehicle crash causing injury or death to occupants.
Corrective Action
Blue bird will notify owners and repair the buses by replacing the screw with a new attaching screw free of charge. The recall began on december 11, 2006. Owners may contact blue bird at 478-822-2242.
Notes
Blue bird recall no. R06ld.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #3 - EQUIPMENT ADAPTIVE
Posted on: 2007-02-08
Description
Certain blue bird 2007 and 2008 vision school buses manufactured between february 9 and october 27, 2006. The lift inner barrier interlock switch system may not detect the presence of a passenger on the inner barrier and allow the platform to move down more than one inch below floor level while occupied which does not conform to federal motor vehicle safety standard no. 403, platform lift systems for motor vehicles.
Consequence
In the event this condition occurs during passenger operations it may be possible for the wheelchair lift to tip backwards onto the platform if the user is backing onto the lift from inside the vehicle and has the small front wheels fully or partially on the inner barrier when the platform was lowered. A standee could loose his or her balance if they were positioned fully or partly on the inner barrier when the platform is lowered. Either condition could cause personal injury.
Corrective Action
Blue bird is working with ricon to repair the buses free of charge (please see 06e101). The recall is expected to begin on or about february 26, 2007. Owners can contact blue bird at 478-822-2242.
Notes
Blue bird recall no. R07lk.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #4 - ELECTRICAL SYSTEM: INSTRUMENT PANEL
Posted on: 2011-03-15
Description
Blue bird is recalling certain model year 2008 through 2010 vision non school buses. The dash instrument panel abs indicator light does not illuminate when the abs circuit is disconnected at the main abs module. Accordingly, these buses fail to conform to the requirements of federal motor vehicle safety standard no. 105, hydraulic and electric brake systems, and fmvss no. 121, air brake systems.
Consequence
In the event the abs circuit disconnects from the main abs module, the bus operator would be unaware of the failure of the abs system and the associated reduced braking function, increasing the risk of a crash.
Corrective Action
Blue bird is currently working with stoneridge to produce software that dealers can use to reprogram the dash instrument panel. Blue bird will notify owners once the software update becomes available. The affected buses will be repaired free of charge. The safety recall began on june 23, 2011. Owners may contact blue bird at 1-478-822-2242.
Notes
Blue bird's recall campaign number is r11sz.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #5 - ENGINE AND ENGINE COOLING
Posted on: 2010-06-28
Description
Blue bird is recalling certain model year 2008 through 2010 all american and vision model school buses manufactured from may 23, 2007 through march 9, 2010, equipped with caterpillar c7 engines. The #5 and #6 fuel lines may crack at the fastening point to the common fuel rail and cause a fuel leak.
Consequence
A fuel leak, in the presence of an ignition source, can result in a vehicle fire.
Corrective Action
Blue bird is working with caterpiller to notify owners and repairs will be performed by authorized caterpillar dealers free of charge. Owners may contact caterpillar toll-free at 1-800-447-4986 or blue bird at 1-478-822-2242.
Notes
Blue bird's recall campaign number is r10rz.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #6 - ENGINE AND ENGINE COOLING
Posted on: 2010-06-28
Description
Blue bird is recalling certain model year 2008 through 2010 all american, vision, and excel 102 model non school buses manufactured from may 17, 2007 through november 13, 2008, equipped with caterpillar c7 engines. The #5 and #6 fuel lines may crack at the fastening point to the common fuel rail and cause a fuel leak.
Consequence
A fuel leak, in the presence of an ignition source, can result in a vehicle fire.
Corrective Action
Blue bird is working with caterpillar to notify owners and repairs will be performed by authorized caterpillar dealers free of charge. The safety recall began on september 9, 2010. Owners may contact caterpillar toll-free at 1-800-447-4986 or blue bird at 1-478-822-2242.
Notes
Blue bird's recall campaign number is r10rz.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #7 - ENGINE AND ENGINE COOLING:ENGINE
Posted on: 2007-09-07
Description
Certain 2008 blue bird vision school buses manufactured from june 6 through september 4, 2007. The oil fill cap may separate from the oil fill tube allowing engine oil to be emitted from the tube. Oil could wet the left front brake shoes/pads resulting in reduced braking capacity.
Consequence
A vehicle crash could occur.
Corrective Action
Blue bird is advising the owners to remove their buses from service until they have the buses repaired and to contact a caterpillar dealer for an interim repair. The interim repair consists of installing two screws through the oil fill tube to retain the oil fill cap in place. Caterpillar will issue a separate recall notification letter to owners on or about september 17, 2007 that will instruct owners to contact a caterpillar dealer to schedule an appointment to have a new oil fill tube installed as a permanent remedy. The recall began on september 7, 2007. Owners can contact blue bird at 478-822-2242 or caterpillar at 800-447-4986.
Notes
Blue bird recall no. R07mj.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #8 - PARKING BRAKE
Posted on: 2007-06-27
Description
Certain my 2007 and 2008 blue bird vision and all american school and transit buses manufactured between december 1, 2005, and may 24, 2007, and equipped with bendix sr-7 spring brake modulating valves. The internal rubber check valve may leak causing a delay in the application of the spring brakes to park the vehicle after the operator pulls the dash valve button.
Consequence
The delayed parking brake application can occur without warning, leading to unintended vehicle rollaway.
Corrective Action
Blue bird will notify owners and provide a free remedy. The recall began on september 30, 2007. Owners can contact blue bird at 478-822-2242.
Notes
Blue bird recall no. R07lx.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #9 - SEATS
Posted on: 2009-08-13
Description
Blue bird is recalling certain model year 2004 through 2010 all american, vision, micro bird, and conventional school buses manufactured between january 30, 2003 and may 7, 2009. Incorrect offset leg barrier pads or 2/3 seat back pads may have been installed. Buses with incorrect pads installed fail to conform to the requirements of federal motor vehicle safety standard no. 222, school bus passenger seating and crash protection.
Consequence
In the event of a crash, there is an increased risk of injury to the seat occupant(s).
Corrective Action
Blue bird will notify owners and the buses will be repaired free of charge. The safety recall began on september 18, 2009. Owners may contact blue bird at 1-478-822-2242.
Notes
Blue bird's recall campaign number is r09pm.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #10 - ELECTRICAL SYSTEM: INSTRUMENT PANEL
Posted on: 2011-03-15
Description
Blue bird is recalling certain model year 2007 through 2011 vision school buses. The dash instrument panel abs indicator light does not illuminate when the abs circuit is disconnected at the main abs module. Accordingly, these buses fail to conform to the requirements of federal motor vehicle safety standard no. 105, hydraulic and electric brake systems, and fmvss no. 121, air brake systems.
Consequence
In the event the abs circuit disconnects from the main abs module, the bus operator would be unaware of the failure of the abs system and the associated reduced braking function, increasing the risk of a crash.
Corrective Action
Blue bird is currently working with stoneridge to produce software that dealers can use to reprogram the dash instrument panel. Blue bird will notify owners once the software update becomes available. The affected buses will be repaired free of charge. The safety recall began on june 23, 2011. Owners may contact blue bird at 1-478-822-2242.
Notes
Blue bird's recall campaign number is r11sz.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #11 - SEATS:BARRIERS
Posted on: 2011-10-14
Description
Blue bird is recalling certain model year 2006 through 2012 all american, 2006 through 2011 vision, and 2006 conventional school buses manufactured between september 19, 2005, and may 3, 2011, equipped with 2-passenger seats installed forward of the 39 barrier. In the event of a crash, the barrier may make contact with the 2-passenger seat installed forward of the barrier. Accordingly, these buses fail to conform with the requirements of federal motor vehicle safety standard no. 222, school bus passenger seating and crash protection.
Consequence
The seat occupants may be seriously injured in the event of a crash.
Corrective Action
Blue bird will notify owners, and dealers will repair the buses free of charge. The safety recall began on january 18, 2012. Owners may contact blue bird at 1-478-822-2242.
Notes
Blue bird's recall campaign number is r11tq.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #12 - SERVICE BRAKES, HYDRAULIC
Posted on: 2008-07-11
Description
The hydraulic brake hoses from the master cylinder to the chassis frame may have been improperly routed or retained on certain 2004 through 2009 my blue bird vision conventional school and transit buses manufactured from january 11, 2004 through april 22, 2008.
Consequence
Improper routing or retention of the hydraulic brake hoses may result in brake hoses chaffing against the bus body and/or chassis components which could cause a leak in the hydraulic brake system resulting in reduced braking capacity which could result in a crash.
Corrective Action
Blue bird will notify owners and inspect and repair the buses free of charge. The recall began on august 8, 2008. Owners may contact blue bird at 1-478-822-2242.
Notes
Blue bird recall no. R08nb.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #13 - SERVICE BRAKES, HYDRAULIC
Posted on: 2008-07-11
Description
The hydraulic brake hoses from the master cylinder to the chassis frame may have been improperly routed or retained on certain 2004 through 2009 my blue bird vision conventional school and transit buses manufactured from january 11, 2004 through april 22, 2008.
Consequence
Improper routing or retention of the hydraulic brake hoses may result in brake hoses chaffing against the bus body and/or chassis components which could cause a leak in the hydraulic brake system resulting in reduced braking capacity which could result in a crash.
Corrective Action
Blue bird will notify owners and inspect and repair the buses free of charge. The recall began on august 8, 2008. Owners may contact blue bird at 1-478-822-2242.
Notes
Blue bird recall no. R08nb.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #14 - ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Posted on: 2008-07-11
Description
A plug on the outlet side of the fuel pump can crack on certain 2008 and 2009 my blue bird all american and vision school buses manufactured from may 23, 2007 through july 4, 2008, equipped with caterpillar c7 engines.
Consequence
A crack in this plug can result in a high pressure fuel spray or leak which, in the presence of an ignition source, could result in a fire.
Corrective Action
Blue bird is working in conjunction with caterpillar to notify owners to contact their local caterpillar dealer for a free remedy. The recall is expected to begin during july 2008. Owners can contact caterpillar at 1-800-447-4986 or blue bird at 1-478-822-2242.
Notes
Blue bird's recall no. R08ng.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #15 - STRUCTURE:BODY:ROOF AND PILLARS
Posted on: 2008-05-20
Description
Blue bird is recalling 23,464 my 2005 through 2009 all american and vision school and transit model buses manufactured from january 22, 2004, and march 28, 2008, and my 2004 through 2007 all american school buses and conventional model school buses manufactured from march 6, 2003, through june 16, 2006. The rivet pattern may be incorrect in sections of the rear roof sheet joint that attaches to the rear roof cap. Without the appropriate amount of roof rivets, the buses fail to conform with the requirements of federal motor vehicle safety standard no 221, joint strength.
Consequence
In the event of a crash, these panels may separate exposing the occupants to increased risk of injury.
Corrective Action
Blue bird will notify owners and inspect and repair the buses by adding additional rivets. The recall began on september 18, 2008. Owners may contact blue bird at 478-822-2242.
Notes
Blue bird recall no. R08nc.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #16 - STRUCTURE:BODY:ROOF AND PILLARS
Posted on: 2008-05-20
Description
Blue bird is recalling 23,464 my 2005 through 2009 all american and vision school and transit model buses manufactured from january 22, 2004, and march 28, 2008, and my 2004 through 2007 all american school buses and conventional model school buses manufactured from march 6, 2003, through june 16, 2006. The rivet pattern may be incorrect in sections of the rear roof sheet joint that attaches to the rear roof cap. Without the appropriate amount of roof rivets, the buses fail to conform with the requirements of federal motor vehicle safety standard no 221, joint strength.
Consequence
In the event of a crash, these panels may separate exposing the occupants to increased risk of injury.
Corrective Action
Blue bird will notify owners and inspect and repair the buses by adding additional rivets. The recall began on september 18, 2008. Owners may contact blue bird at 478-822-2242.
Notes
Blue bird recall no. R08nc.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #17 - OTHER:SCHOOL BUS STOP ARM ASSEMBLY
Posted on: 2009-08-25
Description
Blue bird is recalling certain model year 2008 and 2009 all american, vision, and micro bird school buses manufactured between april 18, 2008 and february 11, 2009, equipped with specialty manufacturing, inc. (smi) 000290 led light kits. A change to the wire used in the led light kits may reduce the effective life of the lights used on the stop arms. The lights may stop functioning without warning.
Consequence
Should the led lights stop functioning, visibility of a stopped bus would be decreased, possibly endangering a child or pedestrian to injury by passing vehicles.
Corrective Action
Blue bird will notify owners and the buses will be repaired free of charge. Repairs will be performed by smi. The safety recall began on september 24, 2009. Owners may contact smi warranty service at 1-800-951-7867 or blue bird at 1-478-822-2242.
Notes
Blue bird's recall campaign number r09ps.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #18 - SEATS
Posted on: 2009-07-06
Description
Blue bird is recalling 69 model year 2008 through 2010 micro bird and vision school buses manufactured from september 29, 2007 through may 2, 2009, equipped with optional 34 inch offset barrier. The offset leg of the barrier frame may have been located incorrectly and incorrect padding may have been installed on the 34 inch offset barriers which fails to comply with the leg protection zone requirements of federal motor vehicle safety standard no. 222, school bus passenger seating and crash protection.
Consequence
Vehicle occupants may suffer injuries in the event of a vehicle crash.
Corrective Action
Blue bird will notify owners and replace the barrier pads with a new designed pad free of charge. The safety recall began on august 12, 2009. Owners may contact blue bird at 1-478-822-2242.
Notes
Blue bird's recall campaign no. R09pj.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #19 - ELECTRICAL SYSTEM
Posted on: 2010-04-23
Description
Blue bird is recalling certain model year 2004 through 2009 vision non-school buses manufactured from september 19, 2003 through july 2, 2008. The power cables running to the power distribution unit stud and driver's control module stud may have been installed with the lug (eyelet) flat side up. When this condition exists, vibration may wear the insulation permitting direct contact between the bare lug and the pdu or dcm which could cause a direct short in the electrical system.
Consequence
This condition could result in a fire.
Corrective Action
Blue bird will notify owners and repair the buses as necessary free of charge. The safety recall began on may 26, 2020. Owners may contact blue bird at 1-478-822-2242.
Notes
Blue bird's recall campaign number is r10rw. Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #20 - ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
Posted on: 2009-03-09
Description
Blue bird is recalling 3,419 my 2008 and 2009 vision conventional school buses manufactured from january 18, 2007 through october 29, 2008, equipped with caterpillar c7 and c7 07 engines. Incorrect bolts and/or spacers may have been installed to attach the fan blade to the fan clutch.
Consequence
As a result, the fan blade may separate from the clutch and potentially cause property damage or personal injury to persons in or near the front of the bus. The vehicle should not be serviced with the hood open and the engine running until the bolts/spacers have been inspected and, if needed, replaced.
Corrective Action
Blue bird will notify owners and dealers will repair the buses free of charge. The safety recall began on april 7, 2009. Owners may contact blue bird at 1-478-822-2242.
Notes
Blue bird's recall number r09pd.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #21 - ELECTRICAL SYSTEM
Posted on: 2010-04-23
Description
Blue bird is recalling certain model year 2004 through 2009 vision school buses manufactured from january 30, 2003 through september 24, 2008. The power cables running to the power distribution unit stud and driver's control module stud may have been installed with the lug (eyelet) flat side up. When this condition exists, vibration may wear the insulation permitting direct contact between the bare lug and the pdu or dcm which could cause a direct short in the electrical system.
Consequence
This condition could result in a fire.
Corrective Action
Blue bird will notify owners and repair the buses as necessary free of charge. The safety recall began may 26, 2020. Owners may contact blue bird at 1-478-822-2242.
Notes
Blue bird's recall campaign number is r10rw.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #22 - STEERING:HYDRAULIC POWER ASSIST SYSTEM
Posted on: 2009-07-23
Description
Blue bird is recalling 7,772 model year 2008 through 2010 vision school buses manufactured from march 27, 2007 through june 10, 2009. The lid gasket on the power steering reservoir may deteriorate and contaminate the power steering fluid which could result in a loss of power steering assist.
Consequence
Loss of power steering assist could result in a vehicle crash.
Corrective Action
Blue bird will notify owners and repair the buses free of charge. The safety recall campaign began on august 11, 2009. Owners may contact blue bird at 1-478-822-2242.
Notes
Blue bird recall campaign no. R09ph.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #23 - ELECTRICAL SYSTEM:BATTERY:CABLES
Posted on: 2009-02-17
Description
Blue bird is recalling 4,591 my 2007 and 2008 vision conventional school buses manufactured from march 29, 2006 through december 3, 2007, equipped with caterpillar c7 engines. The main battery power cable may chafe against the engine components at the rear of the engine.
Consequence
Chafing of the cable can result in a direct short with potential for fire.
Corrective Action
Blue bird will notify owners and inspect and correct the buses free of charge. The recall began on april 2, 2009. Owners may contact blue bird at 1-478-822-2242.
Notes
Blue bird's recall no. R09pb.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #24 - ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Posted on: 2007-08-03
Description
Certain blue bird my 2008 all american and vision school buses manufactured between june 6 and july 27, 2007. A fuel pump failure will dilute the engine oil with fuel and cause loss of throttle control and excessive smoke.
Consequence
Either condition could result in a vehicle crash.
Corrective Action
Blue bird is working in conjunction with caterpillar to notify owners to contact their local caterpillar dealer for a free remedy. The recall is expected to begin during august 2007. Owners can contact caterpillar at 1-800-447-4986 or blue bird at 478-822-2242.
Notes
Blue bird recall no. R07mf.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #25 - STRUCTURE
Posted on: 2013-08-06
Description
Blue bird body company is recalling certain model year 2007-2014 all american and vision school buses manufactured march 10, 2006, through june 18, 2013; and equipped with optional transit sliding windows. Joint adhesive may not have been applied at the interior and exterior body window panel joints. Without the adhesive, these vehicles fail to conform to the standards of federal motor vehicle safety standard (fmvss) no. 221, school bus body joint strength.
Consequence
In the event of a vehicle crash, there is an increased risk that the window panels may separate and fall onto occupants causing injury.
Corrective Action
Blue bird will notify owners, and dealers will install additional rivets at the window panel joints, free of charge. The recall began on august 28, 2013. Owners may contact blue bird at 1-478-825-2021. Blue bird's recall number is r13wm.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #26 - EQUIPMENT ADAPTIVE
Posted on: 2014-08-19
Description
Blue bird body company (blue bird) is recalling certain model year 2007-2015 all american and vision, 2007-2011 micro bird, and 2007-2008 conventional school buses equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured by ricon corporation. The platform side plate of the affected wheelchair lifts may crack.
Consequence
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Corrective Action
Blue bird will notify owners to take buses to a ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on october 1, 2014. Owners may contact blue bird customer service at 1-478-822-2242 or ricon customer service at 1-800-322-2884. Blue bird's number for this recall is r14xn.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #27 - EQUIPMENT ADAPTIVE
Posted on: 2014-08-19
Description
Blue bird body company (blue bird) is recalling certain model year 2007-2015 all american, 2007-2010 micro bird, and 2007-2014 vision non-school buses equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured by ricon corporation. The platform side plate of the affected wheelchair lifts may crack.
Consequence
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Corrective Action
Blue bird will notify owners to take buses to a ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on october 1, 2014. Owners may contact blue bird customer service at 1-478-822-2242 or ricon customer service at 1-800-322-2884. Blue bird's number for this recall is r14xn.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #28 - EQUIPMENT ADAPTIVE
Posted on: 2015-11-04
Description
Blue bird body company (blue bird) is recalling certain model year 2007-2015 all american and vision and 2007-2011 micro bird transit buses equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured january 1, 2006, to august 25, 2014 by the ricon corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence
If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Corrective Action
Blue bird will notify owners, and ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on december 1, 2015. Owners may contact blue bird customer service at 1-478-822-2242, or ricon customer service at 1-800-322-2884.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #29 - ELECTRICAL SYSTEM:BATTERY:CABLES
Posted on: 2016-02-23
Description
Blue bird body company (blue bird) is recalling certain model year 2008-2009 vision school buses manufactured from may 10, 2007, through march 5, 2008 and equipped with caterpillar c707 engines. In the affected buses, the positive starter cable may be incorrectly attached to the same power distribution unit (pdu) stud as the battery cable, exposing the smaller battery cable to a higher current draw during cranking.
Consequence
Exposure to high current draw may cause the battery cable to overheat, melt the wire insulation and increase the risk of a short circuit and a fire.
Corrective Action
Blue bird will notify owners, and dealers will relocate the starter cable to the chassis power stud. Any damaged battery cables will be replaced. These repairs will be made free of charge. The recall began on march 10, 2016. Owners may contact blue bird customer service at 1-478-822-2242. Blue bird's recall number for this campaign is r16yl-sb.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #30 - ELECTRICAL SYSTEM:STARTER ASSEMBLY
Posted on: 2016-02-23
Description
Blue bird body company (blue bird) is recalling certain model year 2008-2009 vision school buses manufactured from may 10, 2007, through march 5, 2008 and equipped with caterpillar c707 engines. In the affected buses, the positive starter cable may be incorrectly attached to the same power distribution unit (pdu) stud as the battery cable, exposing the smaller battery cable to a higher current draw during cranking.
Consequence
Exposure to high current draw may cause the battery cable to overheat, melt the wire insulation and increase the risk of a short circuit and a fire.
Corrective Action
Blue bird will notify owners, and dealers will relocate the starter cable to the chassis power stud. Any damaged battery cables will be replaced. These repairs will be made free of charge. The recall began on march 10, 2016. Owners may contact blue bird customer service at 1-478-822-2242. Blue bird's recall number for this campaign is r16yl-sb.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #31 - ELECTRICAL SYSTEM:WIRING
Posted on: 2016-02-23
Description
Blue bird body company (blue bird) is recalling certain model year 2008-2009 vision school buses manufactured from may 10, 2007, through march 5, 2008 and equipped with caterpillar c707 engines. In the affected buses, the positive starter cable may be incorrectly attached to the same power distribution unit (pdu) stud as the battery cable, exposing the smaller battery cable to a higher current draw during cranking.
Consequence
Exposure to high current draw may cause the battery cable to overheat, melt the wire insulation and increase the risk of a short circuit and a fire.
Corrective Action
Blue bird will notify owners, and dealers will relocate the starter cable to the chassis power stud. Any damaged battery cables will be replaced. These repairs will be made free of charge. The recall began on march 10, 2016. Owners may contact blue bird customer service at 1-478-822-2242. Blue bird's recall number for this campaign is r16yl-sb.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #32 - EQUIPMENT ADAPTIVE
Posted on: 2015-11-04
Description
Blue bird body company (blue bird) is recalling certain model year 2007-2015 all american, vision, 2007-2011 micro bird, and 2007-2008 conventional school buses, equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured january 1, 2006, to august 25, 2014 by the ricon corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence
If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Corrective Action
Blue bird will notify owners, and ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on december 1, 2015. Owners may contact blue bird customer service at 1-478-822-2242, or ricon customer service at 1-800-322-2884.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #33 - PARKING BRAKE
Posted on: 2020-04-28
Description
Blue bird body company (blue bird) is recalling certain 2006-2021 vision and 2007-2013 all american school buses. The floor-mounted parking brake may fail to hold the vehicle stationary on an incline when the vehicle is loaded to its maximum weight, due to an insufficient application force. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 105, hydraulic and electric brake systems.
Consequence
A parking brake system that is set to an insufficient application force may result in an increased possibility of unintended vehicle movement, which increases the risk of a crash.
Corrective Action
Blue bird will notify owners, and dealers will inspect the floor mounted park brake application force hand lever assembly and correct the application force, as necessary, free of charge. The recall is expected to begin june 24, 2020. Owners may contact blue bird customer service at 478-822-2242. Blue bird's number for this recall is r20ao-sb.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #34 - PARKING BRAKE
Posted on: 2020-04-28
Description
Blue bird body company (blue bird) is recalling certain 2006-2021 vision and 2007-2013 all american school buses. The floor-mounted parking brake may fail to hold the vehicle stationary on an incline when the vehicle is loaded to its maximum weight, due to an insufficient application force. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 105, hydraulic and electric brake systems.
Consequence
A parking brake system that is set to an insufficient application force may result in an increased possibility of unintended vehicle movement, which increases the risk of a crash.
Corrective Action
Blue bird will notify owners, and dealers will inspect the floor mounted park brake application force hand lever assembly and correct the application force, as necessary, free of charge. The recall is expected to begin june 24, 2020. Owners may contact blue bird customer service at 478-822-2242. Blue bird's number for this recall is r20ao-sb.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #35 - SEATS:BARRIERS
Posted on: 2020-03-04
Description
Blue bird body company (blue bird) is recalling certain 2008-2021 vision and all american school buses. The seat barrier behind the driver seat with an integrated 3-point seat belt may have been installed incorrectly and may be missing the reinforcing bracket. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 222, school bus passenger seating and crash protection.
Consequence
In the event of a crash, the seat barrier may not adequately protect the occupant seated behind the seat barrier separating them from the driver seat with integrated 3-point seat belt, increasing the risk of injury.
Corrective Action
Blue bird will notify owners, and dealers will inspect and properly install the seat barrier including adding reinforcing bracket, as necessary, free of charge. The recall is expected to begin april 23, 2020. Owners may contact blue bird customer service at 1-478-822-2242. Blue bird's number for this recall is r20am-sb.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #36 - SEATS:BARRIERS
Posted on: 2020-03-04
Description
Blue bird body company (blue bird) is recalling certain 2008-2021 vision and all american school buses. The seat barrier behind the driver seat with an integrated 3-point seat belt may have been installed incorrectly and may be missing the reinforcing bracket. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 222, school bus passenger seating and crash protection.
Consequence
In the event of a crash, the seat barrier may not adequately protect the occupant seated behind the seat barrier separating them from the driver seat with integrated 3-point seat belt, increasing the risk of injury.
Corrective Action
Blue bird will notify owners, and dealers will inspect and properly install the seat barrier including adding reinforcing bracket, as necessary, free of charge. The recall is expected to begin april 23, 2020. Owners may contact blue bird customer service at 1-478-822-2242. Blue bird's number for this recall is r20am-sb.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.