14 recalls found. |
DEFECT #1 - ENGINE AND ENGINE COOLING
Posted on: 2011-02-16
Description
Pierce is recalling certain model year 2008-2009 arrow xt vehicles built with caterpillar c13 2007 engines. The three upper air cleaner bracket fasteners may loosen and fall out. If this occurs the air cleaner and bracket may fall onto the engine and start a fire.
Consequence
If an under cab fire occurs, the engine operation could be affected and a crash may occur.
Corrective Action
Pierce will notify owners and dealers will repair the vehicles free of charge. The safety recall is expected to begin during may 2011. Owners may contact pierce at 1-888-974-3723.
Notes
Pierce safety recall no. 74b211.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #2 - AIR BAGS: ROLL PROTECTION
Posted on: 2009-08-31
Description
Pierce is recalling certain model year 2007 through 2009 fire trucks equipped with side-roll protection systems. The sensor designed to detect vehicle roll can malfunction resulting in an inadvertent deployment of the protection system.
Consequence
Inadvertent deployment of the side-roll protection system could result in a vehicle crash or injury to an out of position occupant.
Corrective Action
Pierce will notify owners and the vehicles will be repaired free of charge. The safety recall began on august 31, 2009. Owners may contact pierce toll-free at 1-888-974-3723.
Notes
Pierce's recall campaign number 39-0139830.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #3 - ENGINE AND ENGINE COOLING
Posted on: 2009-10-06
Description
Pierce is recalling certain model year 2008 and 2009 fire trucks manufactured between april 1, 2008 and september 30, 2009, equipped with cummins isb cm2150, isc cm2150, isl cm2150, ism cm876, and isx cm871 model diesel engines. The vehicles may be designed with a hard wired, dash-mounted switch that enables the vehicle operator to inhibit aftertreatment diesel particulate filter regeneration in environments where the operator believes it may be unsafe for elevated exhaust temperatures. Due to an issue with the logic in the ecm software in these engines, the switch may not function correctly, leading the operator to believe that the switch is in inhibit mode when it is not.
Consequence
This condition will permit hot exhaust gases to exit the vehicle tailpipe, increasing the risk of melting or burning of nearby surfaces, or a fire.
Corrective Action
Pierce is working with cummins to repair the engines. Cummins is conducting this campaign and will provide the remedy free of charge. Please see cummins recall campaign 09e-046. The safety recall is expected to begin during october 2009. Owners may contact cummins at 1-800-diesels (1-800-343-7357) or pierce at 1-920-832-3000.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #4 - STEERING
Posted on: 2010-09-22
Description
Pierce is recalling certain model year 1998 through 2008 arrow xt, lance, velocity, enforcer, impel, and dash custom fire apparatus vehicles manufactured from may 30, 1998 through november 25, 2008. The steering gear bracket may fracture and break. If this occurs the steering gear may detach from the vehicle.
Consequence
Detachment of the steering gear will result in a loss of steering control that could cause a crash.
Corrective Action
Pierce will notify owners and dealers will install a new steering gear mounting bracket free of charge. The safety recall began on october 12, 2010. Owners are being instructed to inspect the steering gear bracket prior to each trip. The remedy to repair this defect is expected to begin no earlier the january 31, 2011. Owners may contact pierce at 1-888-974-3723.
Notes
Pierce safety recall no. 74b207.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #5 - VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Posted on: 2011-04-28
Description
Pierce is recalling certain model year 1999-2008 arrow xt, dash, lance, and enforcer fire apparatus manufactured from june 22, 1999, through may 12, 2008, and equipped with an electronic accelerator pedal. After repeated use with excessive force, the accelerator pedal arm may bend and cause the pedal to move closer to the floor. If the pedal arm bends far enough, the pedal may contact the cab floor without warning and stick in the full throttle position.
Consequence
If the accelerator pedal becomes stuck, the operator may lose control of the vehicle increasing the risk of a crash.
Corrective Action
Dealers will remove the existing accelerator arm and install a redesigned pedal arm free of charge. The safety recall is expected to begin on or about may 9, 2011. Owners may contact pierce at 1-920-832-3000.
Notes
Pierce safety recall no. 74b215.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #6 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
Posted on: 2010-07-08
Description
Pierce is recalling certain model year 2006 through 2010 arrow xt, dash, enforcer, impel, quantum, and velocity fire trucks manufactured from october 11, 2006 through june 16, 2010 and equipped with meritor wabco ex225 rear disc brakes and onspot automatic tire chains. The meritor wabco ex225 rear disc brake caliper may interfere with the onspot automatic tire chain brackets. This interference may restrict the caliper from full movement.
Consequence
If this interference occurs, braking performance may be reduced without warning and a crash may occur.
Corrective Action
Dealers will install new automatic tire chain brackets. The new brackets provide additional clearance for the full actuation of the disc brake calipers. This service will be performed free of charge. The safety recall began in july 2010. Owners may contact pierce at 1-920-832-3000.
Notes
Pierce safety recall no. 39-0139830. Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #7 - STEERING
Posted on: 2009-06-08
Description
Pierce is recalling 185 model year 2008 and 2009 custom fire trucks manufactured between january 1, 2008 and may 31, 2009, equipped with meritor wabco steering angle sensors (sas). Internal friction can develop between the sensor gears and the sensor housing as a result of external forces experienced on the vehicle including vibration. If developed friction is great enough, the driving tab of the sas can shear as the driver turns the steering wheel.
Consequence
With a broken sas driving tab, the electronic stability control (esc) will not function properly, which could possibly result in a vehicle crash.
Corrective Action
Pierce will notify owners and the vehicles will be repaired free of charge. The safety recall began on july 2, 2009. Owners may contact pierce at 1-920-832-3000.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #8 - ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Posted on: 2008-10-31
Description
Pierce is recalling 76 my 2007-2008 arrow xt and velocity fire trucks equipped with caterpillar c13 diesel engines. The extension pipes attached to the aftertreatment regeneration device (ard) may develop a hole, and heat and flame may escape during a regeneration of the diesel particulate filter.
Consequence
This may result in a fire hazard.
Corrective Action
Pierce is working with caterpillar to repair these vehicles (please see 08e054). Owners may contact caterpillar at 1-800-447-4986 or pierce at 1-920-832-3000.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #9 - LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Posted on: 2009-04-28
Description
Pierce manufacturing is recalling 257 my 2008 emergency vehicles manufactured between june 1 and october 31, 2008, equipped with trimark door latches. These latches fail to comply with the transverse pull static load requirements of federal motor vehicle safety standard no 206, door locks and door retention components. The latches may pop into the secondary locking position.
Consequence
In the event of a vehicle crash, the door would not have primary closing security which could possibly lead to injury of the vehicle occupant.
Corrective Action
Pierce will notify owners and repair the vehicles free of charge. The safety recall began on may 4, 2009. Owners may contact pierce customer service toll-free at 1-888-974-3723.
Notes
Pierce's recall no. 39-0139830.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #10 - ENGINE AND ENGINE COOLING
Posted on: 2010-05-10
Description
Pierce is recalling certain model year 2006 through 2010 arrow xt, dash, lance, quantum, and velocity emergency vehicles manufactured from december 20, 2006, through february 1, 2010, equipped with detroit diesel series 60 engines. The engine may shut down unexpectedly when a diesel particulate filter over temperature condition is detected.
Consequence
Unexpected emergency vehicle engine shutdown under certain conditions could hamper rescue operations and place the public at risk.
Corrective Action
Owners will be notified by detroit diesel and detroit diesel will repair the vehicles free of charge by reprogramming the engine control logic to illuminate a malfunction indicator light without requesting engine shutdown. Please see daimler trucks' defect report 10e-005. The safety recall began on may 28, 2010. Owners may contact daimler trucks at 1-800-547-0712 or pierce at 1-920-832-3000.
Notes
Pierce's recall campaign number is 39-0139830.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #11 - STRUCTURE:BODY:DOOR
Posted on: 2011-11-18
Description
Pierce manufacturing (pierce) is recalling certain model year 2005, 2008-2011 arrow xt, custom contender, dash, enforcer, impel, quantum, saber, and velocity 75 foot hal (heavy aluminum ladder) fire apparatus bodies vehicles manufactured from may 17,2005, through october 13, 2011, that may be equipped with dual scba cylinder storage compartments. These compartments extend inboard horizontally from the side of the rear body. The scba compartment door latch orientation may have been manufactured incorrectly, allowing the door to accidentally open while the vehicle is in motion. The door may open without warning and without knowledge to the driver.
Consequence
If the door opens, the scba cylinders may fall out of the compartment and onto the roadway, increasing the risk of a crash or injury to pedestrians.
Corrective Action
Pierce dealers will notify owners, and will install a flat reinforcement plate that spans the length of the scba door. This service will be performed free of charge. The safety recall began on december 5, 2011. Owners may contact pierce at 1-920-832-3000.
Notes
Pierce safety recall number is 74b186.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #12 - ELECTRONIC STABILITY CONTROL
Posted on: 2011-11-02
Description
Pierce manufacturing (pierce) is recalling certain model year 2007-2011 arrow xtand velocity, model year 2008-2011 custom contender, impel, quantum and model year 2009-2011 saber emergency trucks, equipped with meritor wabco electronic stability control (esc) modules, manufactured from december 19, 2007, through october 7, 2011. Under certain road and driving conditions, vehicle body roll and road inclination characteristics may adversely affect the slip angle calculation of the electronic stability control (esc) system. This might cause the esc to perceive an over steering situation and therefore apply the outer wheel brake on the front axle until the vehicle is perceived to be stable.
Consequence
If the driver is slow to react during this esc intervention, the vehicle may deviate from the intended line of travel, increasing the risk of a crash.
Corrective Action
Pierce is working with meritor wabco and will replace the control module free of charge. The safety recall began on december 16, 2011. Owners may contact meritor wabco at 1-248-435-8001 or pierce at 1-920-832-3000.
Notes
The nhtsa number assigned to the meritor wabco's recall is 11e-039.pierce's safety recall number is 74b226.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #13 - EQUIPMENT
Posted on: 2013-11-07
Description
Pierce manufacturing inc. (pierce) is recalling certain model year 2000-2009 enforcer and model year 2000-2010 dash, lance, and arrow xt vehicles. While raising or lowering the cab as part of vehicle maintenance, the mounts on which the cab tilt cylinders pivot may fatigue and fail allowing the cab to fall until the safety catch activates.
Consequence
If a person is in the path of the moving cab when a mount fails, the person may be hit by the falling cab, increasing the risk of injury.
Corrective Action
Pierce will notify owners, and dealers will affix new safety signs advising the operator to stay clear of the cab while it is being tilted, free of charge. The recall began on january 6, 2014. Owners may contact pierce at 1-920-832-3000. Pierce's recall number is 74b240.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #14 - ELECTRICAL SYSTEM:SOFTWARE
Posted on: 2019-01-31
Description
Pierce manufacturing (pierce) is recalling certain 2004-2018 arrow xt, dash, enforcer, impel, quantum and velocity aerial vehicles. The aerial device may unexpectedly rotate to the right when the ladder is being extended.
Consequence
If the aerial device moves in an unexpected direction, the ladder may contact an object, such as a building or an electrical wire, increasing the risk of injury.
Corrective Action
Pierce will notify owners, and dealers will reprogram the aerial control module, free of charge. The recall began february 28, 2019. Owners may contact pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74b295.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.