7 recalls found. |
DEFECT #1 - TRAILER HITCHES
Posted on: 2009-02-27
Description
Tiffin is recalling 1,408 my 2006-2009 allegro bus, my 2007-2009 phaeton and my 2005-2009 zephyr vehicles built on spartan chassis and equipped with putman hitches. Certain trailer hitches may fracture which could result in the loss of the trailer.
Consequence
Suspect hitches may develop fractures and subsequent separation may occur, resulting in a vehicle crash, property damage or pedestrian harm.
Corrective Action
Tiffin is working with spartan and spartan is handling the remedy for this campaign (please see 08v-567). The trailer hitch will be replaced free of charge. Owners may contact spartan at 1-517-543-6400 or tiffin at 256-356-8661.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #2 - STEERING:GEAR BOX:SHAFT PITMAN
Posted on: 2008-01-25
Description
Certain motor homes built on freightliner chassis and equipped with zf model 8018 steering gears may have been assembled with the incorrect recirculating ball spacer. This could potentially allow the recirculating balls to escape from the recirculating ball circuit resulting in a loss of steering.
Consequence
The operator may notice higher required steering wheel inputs, or the need for more steering wheel adjustments while driving in a straight line in combination with metallic cracking noises prior to a loss of steering. Loss of steering could result in a vehicle crash.
Corrective Action
Tiffin is working with freightliner to replace the steering gear free of charge (please see 07v343 and 07e049). Owners may contact freightliner at 1-800-547-0712 or tiffin at 256-356-8661.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #3 - SUSPENSION
Posted on: 2008-06-18
Description
Daimler trucks is recalling 2,506 my 2008 xc motor home chassis and thomas built hdx school and transit buses equipped with saf-holland adl series rear suspensions. In some instances the transverse beam was not properly welded which could result in a failure of the weld.
Consequence
If the weld fails, vehicle stability while cornering could be affected resulting in loss of vehicle control, possibly resulting in a crash. In addition, the transverse beam could drop to the ground causing sparks that could cause a fire hazard.
Corrective Action
Daimler trucks is working with saf-holland to have a visual inspection of the adl transverse beam performed. If a weld defect is identified, saf-holland will provide a service replacement kit that contains a new transverse beam, all necessary installation hardware, beam replacement, and instructions free of charge (please see 08e031). The recall recall began on september 12, 2008 (thomas built buses) and october 8, 2008. Owners may contact saf-holland at 1-231-773-3271 or daimler trucks at 1-800-547-0712.
Notes
Daimler trucks recall no. Fl-530.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #4 - SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
Posted on: 2009-12-29
Description
Tiffin is recalling certain model year 2008 through 2010 allegro bus models with powerglide chassis equipped with pneumatic and hydraulic adjustable brake pedal assemblies p/nos. 6562618, 6565118, 77025-001, 77025-002, 77025-501, 77050-004, supplied by kongsberg automotive. Some assemblies could contain a drive pin that is below specification and may become disengaged from the brake arm causing separation or loosening of the pedal from the remainder of the assembly.
Consequence
If the drive pin becomes disengaged on the brake pedal assembly, it could result in a loss of vehicle braking function and/or cause the brake pedal to interfere with the throttle pedal function. Either condition could result in a vehicle crash.
Corrective Action
Tiffin is working with kongsberg to remedy these motorhomes. Please see kongsberg's defect report 09e-064. Kongsberg will supply kits to tiffin. The remedy will be performed by tiffin free of charge. The safety recall began on january 19, 2010. Owners may contact tiffin at 1-256-356-8661.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #5 - SERVICE BRAKES, AIR:ANTILOCK
Posted on: 2009-04-16
Description
Tiffin is recalling 329 my 2008-2009 allegro buses. The rear axle abs modulating valve have the potential to be wired incorrectly. The right and left modulator valve harness pin could possibly be reversed at the abs electronic control unit (ecu) connector.
Consequence
Under slippery road conditions, when in the abs mode, this wiring problem has the potential to cause one side of the rear wheels to lock while causing little or no braking effort on the opposite side. This may result in a loss of control and a vehicle crash.
Corrective Action
Dealers will remove the reversed pins from the ecu connector and insert them back into their correct position free of charge. The recall is expected to begin during april 2009. Owners may contact tiffin at 256-356-8661.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #6 - ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS
Posted on: 2007-08-16
Description
On certain motor home chassis, there may be a loose connection between the bus bar and a grid pad due to the pins being slightly smaller diameters after assembly. Electrical power may be lost to components of the major chassis operating systems (engine, transmission, starting, cooling) causing the vehicle to shut down and/or not be capable of powering up.
Consequence
Each vehicle could potentially experience a unique circumstance where one or a combination of the following conditions could occur: loss of electrical power to the engine, transmission, starting and engine cooling systems, operation of the right chassis stop/turn signal and right trailer stop/turn signal, the anti-lock brake system, auxiliary brake system, the heater elements in the air dryer, and the heater element in the water-in-fuel separator.
Corrective Action
The dvec bussmann box will be replaced. The recall began on january 16, 2008. Owners may contact spartan at 1-517-543-6400.
Notes
Spartan recall no. 07025.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #7 - VISIBILITY:WINDSHIELD WIPER/WASHER
Posted on: 2016-07-13
Description
Tiffin motorhomes, inc. (tiffin) is recalling certain model year 2007-2011 allegro, allegro bus, phaeton, and zephyr motorhomes, 2007-2010 allegro bay motorhomes, and 2010-2011 allegro breeze motorhomes. The windshield wiper arms on the affected vehicles may break off.
Consequence
If the windshield wiper arms break, the driver's visibility may be reduced, increasing the risk of a crash.
Corrective Action
Tiffin will notify owners, and dealers will replace the wiper blade arms, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is tiff-100.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.