8 recalls found. |
DEFECT #1 - EQUIPMENT ADAPTIVE
Posted on: 2010-04-02
Description
Champion bus has notified nhtsa about a defect in certain model year 2008-2010 buses manufactured between september 2007 and february 2010, equipped with certain ricon s series and k series l-model wheelchair lifts, due to a problem in the software that controls the lift's up function. If the up switch is released before the floor level limit switch is activated, the lift may continue its upward travel for approximately 1 second before stopping. The continued upward travel may overrun the floor level cut off point.
Consequence
When the platform overruns the vehicle floor level and stops at an angle from 15-20 degrees, it is possible for a person in a wheelchair to tip over and for someone standing on the platform to fall, possibly resulting in injuries.
Corrective Action
Champion bus will notify owners and the repairs will be performed by authorized ricon dealers please see ricon's defect report 09e-061. Ricon will provide owners with a bulletin outlining proper wheelchair lift operation and will ship owners a dvd-based training aid to promote proper lift operation. The safety recall is expected to begin during may 2010. Owners may contact ricon customer service at 800- 322-2884, emailing at www.dmata@wabtec.com.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #2 - EQUIPMENT:AIR CONDITIONER
Posted on: 2011-03-03
Description
Champion bus is recalling certain vehicles equipped with carrier genv em-1 evaporator units. Due to time, temperature, and/or vibration, the fuse may loosen in the fuse holder resulting in high resistance and arcing.
Consequence
If sufficient arcing occurs, the fuse holder may melt, and may be accompanied by flame, smoke and potential fire.
Corrective Action
Champion bus will notify owners and provide information on how to obtain the retrofit kit from carrier along with repair instructions. This service will be performed free of charge. The safety recall began on march 8, 2011. Owner may contact carrier at 1-800-793-4741 or champion bus at 1-810-724-6474.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #3 - EQUIPMENT ADAPTIVE
Posted on: 2012-06-18
Description
Champion bus is recalling certain model year 2008 through 2011 transit buses equipped with braun century-2 and/or vista-2 wheelchair lifts. Over time and with frequent use, the roll stop latches on the outer barrier may become bent or misaligned.
Consequence
A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. If this occurs when the lift platform is in an elevated position, the wheelchair¿s occupant could fall and sustain injury.
Corrective Action
Champion bus will notify owners, and the repairs will be performed by authorized braun dealers free of charge. The safety recall began on august 17, 2012. Owners may contact champion bus at 1-810-724-6474.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #4 - EQUIPMENT
Posted on: 2012-12-18
Description
Champion bus is recalling certain model year 2006, and certain model year 2008-2013 buses, models: american crusader, challenger, crusader, and defender; manufactured september 30, 2006, through november 16, 2012. The buses are equipped with a ricon manufactured wheelchair lift which has an optional armored pendant cable. The cable may have been installed such that it doesn't clear the wheelchair lift and without a protective cover, or a misinstalled protective cover.
Consequence
The cable may contact the power lug at the base of the wheel chair lift causing a short circuit that could result in a fire.
Corrective Action
Champion bus is working with ricon to notify owners. Ricon will provide a supplemental cover kit with instructions, free of charge. Owners may contact champion bus at 1-819-724-6474 or ricon at 1-818-267-3000.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #5 - EQUIPMENT:ELECTRICAL
Posted on: 2013-09-24
Description
Champion bus is recalling certain model year 2010 american crusader, american coach, cts-fe, cts-re, and ic low floor buses; and 2009-2010 challenger and crusader buses; and 2009-2011 defender and ez trans buses; and 2010-2011 ic high floor buses. The buses are manufactured from august 1, 2009, through may 19, 2011, and equipped with a&m systems door headers containing model 3230 circuit boards. Voltage spikes may damage electrical components and electrical circuits, causing the circuit board to develop high resistance.
Consequence
High resistance may cause the board to overheat, increasing the risk of a fire.
Corrective Action
Champion bus will notify owners, and dealers will inspect the door header and replace any defective circuit board, free of charge. The recall began on october 22, 2013. Owners may contact champion at 1-810-724-6474.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #6 - EQUIPMENT ADAPTIVE
Posted on: 2014-11-19
Description
Champion bus, inc. (champion bus) is recalling certain model year 2006-2014 american coach, american crusader, challenger, corporal, crusader, cts-fe, cts-re, defender, hcac, hc american, platinum shuttle, and stacked rail transit buses manufactured january 1, 2006, to july 31, 2014, equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts manufactured by ricon corporation. The platform side plate of the affected wheelchair lifts may crack.
Consequence
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Corrective Action
Champion bus will notify owners to take buses to a ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began in november 2014. Owners may contact champion bus customer service at 1-810-724-6474. Owners may contact ricon customer service at 1-800-322-2884.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #7 - EQUIPMENT ADAPTIVE
Posted on: 2015-11-16
Description
Champion bus, inc. (champion) is recalling certain model year 2006-2015 challenger, defender, crusader, american, american coach, american crusader, corporal, cts-fe, cts-re, hc american, platinum shuttle, and stacked rail transit buses manufactured january 1, 2006, to august 25, 2015, equipped with certain model s2005, s2010, s5005, s5010, s5505, and s5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence
If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Corrective Action
Champion will notify owners, and ricon will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on december 21, 2015. Owners may contact champion customer service at 1-810-724-1753 extension 415, or ricon customer service at 1-800-322-2884. Champion's number for this recall is 15e-068. Note: these buses and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #8 - SEATS
Posted on: 2016-01-13
Description
Champion bus, inc. (champion) is recalling certain model year 2009-2015 crusader, stacked rail, and cts re vehicles manufactured april 5, 2010, to october 14, 2015, equipped with recaro ergo-m commercial bus driver seats. The affected seats have j-brackets that may be missing welds which could allow the seat belt anchorage assembly to separate from the j-bracket.
Consequence
If the seatbelt anchorage assembly separates from the j-bracket, the bus driver may not be properly restrained in the event of a crash increasing their risk of injury.
Corrective Action
Champion will notify owners, and dealers will inspect the seats to determine if welds are missing. Any j-bracket that is missing welds will be removed and replaced, free of charge. The recall began on february 25, 2016. Owners may contact champion customer service at 1-810-724-6474, or johnson controls (manufacturer of recaro seats) customer service at 1-248-484-3203.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.