2 recalls found. |
DEFECT #1 - EQUIPMENT ADAPTIVE
Posted on: 2010-04-02
Description
Champion bus has notified nhtsa about a defect in certain model year 2008-2010 buses manufactured between september 2007 and february 2010, equipped with certain ricon s series and k series l-model wheelchair lifts, due to a problem in the software that controls the lift's up function. If the up switch is released before the floor level limit switch is activated, the lift may continue its upward travel for approximately 1 second before stopping. The continued upward travel may overrun the floor level cut off point.
Consequence
When the platform overruns the vehicle floor level and stops at an angle from 15-20 degrees, it is possible for a person in a wheelchair to tip over and for someone standing on the platform to fall, possibly resulting in injuries.
Corrective Action
Champion bus will notify owners and the repairs will be performed by authorized ricon dealers please see ricon's defect report 09e-061. Ricon will provide owners with a bulletin outlining proper wheelchair lift operation and will ship owners a dvd-based training aid to promote proper lift operation. The safety recall is expected to begin during may 2010. Owners may contact ricon customer service at 800- 322-2884, emailing at www.dmata@wabtec.com.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #2 - EQUIPMENT ADAPTIVE
Posted on: 2010-04-02
Description
Champion bus has notified nhtsa of a defect in certain model year 2007-2010 buses fitted with ricon public use lifts. The restraint belt on these lifts was designed to prevent the lift from moving, unless the tongue of the belt is fully engaged and latched in the buckle. Ricon has discovered, however, that it is possible for the operator to insert the belt tongue into the buckle without fully engaging the latching mechanism. In this case, the restraint belt would appear to be latched, and the operator could run the lift. If the restraint belt tongue is not fully engaged into the restraint belt buckle, and latched, the lift may operate with an occupant on the platform.
Consequence
The user of the lift could be injured should the lift move without the restraint belt properly buckled.
Corrective Action
Champion bus is working with ricon and ricon will be handling the remedy for this campaign. Please see ricon's defect report 09e-060. Ricon will provide customers with a warning decal and a dvd-based training aid. The safety recall began on may 5, 2010. Owners may contact ricon customer service at 800-322-2884, emailing at www.dmata@wabtec.com.
Notes
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .