11 recalls found. |
DEFECT #1 - TIRES
Posted on: 2015-11-09
Description
Paccar incorporated (paccar) is recalling certain model year 2009-2010 peterbilt 340, 2010, 2012, and 2015-2016 peterbilt 337, 2010 peterbilt 335, 2011-2016 peterbilt 348, 2009 and 2011-2016 peterbilt 365, 2009 and 2012-2013 peterbilt 386, 2009-2015 peterbilt 388, 2015-2016 peterbilt 389, and 2015 peterbilt 567 auto hauler vehicles. The affected trucks are equipped with michelin 295/60r22.5 xza-2 front tires that have a speed rating less than the vehicle is governed to.
Consequence
Higher vehicle speeds and other factors such as tire load and road temperatures may result in premature tire failure, increasing the risk of a crash.
Corrective Action
Peterbilt will notify owners, and dealers will reprogram the engine's vehicle speed parameters to limit the maximum vehicle speed to the tire speed rating, free of charge. The recall began on january 4, 2016. Owners may contact peterbilt customer service at 1-940-591-4000. Paccar's number for this recall is 1115p.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #2 - ENGINE AND ENGINE COOLING:ENGINE
Posted on: 2015-09-24
Description
Paccar incorporated (paccar) is recalling certain model year 2016 kenworth t370, t660, t680, t800, t880, and w900 vehicles manufactured july 31, 2015, to august 12, 2015, and 2016 peterbilt 337, 348, 365, 367, 382, 386, 389, 567, 579, and 587 vehicles manufactured august 4, 2015, to august 12, 2015. In the affected vehicles, the engine control module (ecm) may short circuit, causing the engine to stall without warning.
Consequence
An engine that stalls without warning increases the risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will replace the defective engine control modules, free of charge. The recall began on october 22, 2015. Owners may contact kenworth customer service at 1-425-828-5000 or peterbilt customer service at 1-940-591-4000. Paccar's numbers for this recall are 15kwm (kenworth) and 915-l (peterbilt).
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #3 - ELECTRICAL SYSTEM:IGNITION:MODULE
Posted on: 2015-09-24
Description
Paccar incorporated (paccar) is recalling certain model year 2016 kenworth t370, t660, t680, t800, t880, and w900 vehicles manufactured july 31, 2015, to august 12, 2015, and 2016 peterbilt 337, 348, 365, 367, 382, 386, 389, 567, 579, and 587 vehicles manufactured august 4, 2015, to august 12, 2015. In the affected vehicles, the engine control module (ecm) may short circuit, causing the engine to stall without warning.
Consequence
An engine that stalls without warning increases the risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will replace the defective engine control modules, free of charge. The recall began on october 22, 2015. Owners may contact kenworth customer service at 1-425-828-5000 or peterbilt customer service at 1-940-591-4000. Paccar's numbers for this recall are 15kwm (kenworth) and 915-l (peterbilt).
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #4 - STEERING
Posted on: 2017-09-26
Description
Paccar incorporated (paccar) is recalling certain 2016 peterbilt 220, 320, 325, 330, 337, 348, 365, 367, 382, 384, 386, 389, 389g, 567, 579 and 587 trucks and kenworth k170, t170, t270, t370, t440, t470,t660, t680, t800, t880, and w900 trucks equipped with certain spicer d or e series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Consequence
If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on november 13, 2017. Owners may contact peterbilt customer service at 1-940-591-4000 or kenworth customer service at 1-425-828-5000. Paccar's number for this recall is p817-c.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #5 - STEERING:LINKAGES:TIE ROD ASSEMBLY
Posted on: 2017-09-26
Description
Paccar incorporated (paccar) is recalling certain 2016 peterbilt 220, 320, 325, 330, 337, 348, 365, 367, 382, 384, 386, 389, 389g, 567, 579 and 587 trucks and kenworth k170, t170, t270, t370, t440, t470,t660, t680, t800, t880, and w900 trucks equipped with certain spicer d or e series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Consequence
If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on november 13, 2017. Owners may contact peterbilt customer service at 1-940-591-4000 or kenworth customer service at 1-425-828-5000. Paccar's number for this recall is p817-c.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #6 - STEERING
Posted on: 2017-09-26
Description
Paccar incorporated (paccar) is recalling certain 2016 peterbilt 220, 320, 325, 330, 337, 348, 365, 367, 382, 384, 386, 389, 389g, 567, 579 and 587 trucks and kenworth k170, t170, t270, t370, t440, t470,t660, t680, t800, t880, and w900 trucks equipped with certain spicer d or e series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Consequence
If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on november 13, 2017. Owners may contact peterbilt customer service at 1-940-591-4000 or kenworth customer service at 1-425-828-5000. Paccar's number for this recall is p817-c.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #7 - STEERING:LINKAGES:TIE ROD ASSEMBLY
Posted on: 2017-09-26
Description
Paccar incorporated (paccar) is recalling certain 2016 peterbilt 220, 320, 325, 330, 337, 348, 365, 367, 382, 384, 386, 389, 389g, 567, 579 and 587 trucks and kenworth k170, t170, t270, t370, t440, t470,t660, t680, t800, t880, and w900 trucks equipped with certain spicer d or e series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Consequence
If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on november 13, 2017. Owners may contact peterbilt customer service at 1-940-591-4000 or kenworth customer service at 1-425-828-5000. Paccar's number for this recall is p817-c.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #8 - STEERING
Posted on: 2017-09-26
Description
Paccar incorporated (paccar) is recalling certain 2016 peterbilt 220, 320, 325, 330, 337, 348, 365, 367, 382, 384, 386, 389, 389g, 567, 579 and 587 trucks and kenworth k170, t170, t270, t370, t440, t470,t660, t680, t800, t880, and w900 trucks equipped with certain spicer d or e series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Consequence
If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on november 13, 2017. Owners may contact peterbilt customer service at 1-940-591-4000 or kenworth customer service at 1-425-828-5000. Paccar's number for this recall is p817-c.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #9 - STEERING:LINKAGES:TIE ROD ASSEMBLY
Posted on: 2017-09-26
Description
Paccar incorporated (paccar) is recalling certain 2016 peterbilt 220, 320, 325, 330, 337, 348, 365, 367, 382, 384, 386, 389, 389g, 567, 579 and 587 trucks and kenworth k170, t170, t270, t370, t440, t470,t660, t680, t800, t880, and w900 trucks equipped with certain spicer d or e series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Consequence
If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on november 13, 2017. Owners may contact peterbilt customer service at 1-940-591-4000 or kenworth customer service at 1-425-828-5000. Paccar's number for this recall is p817-c.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #10 - SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT
Posted on: 2020-04-07
Description
Paccar incorporated (paccar) is recalling certain 2008-2019 peterbilt 330, 335, 337, 340, 348, 365, 367, 384, 386, 387, 388, 389, 567, 579 and 587 vehicles and 2008-2020 kenworth t170, t270, t370, t660, t680, t800, t880, and w900 vehicles equipped with namux software. In the event that the anti-lock brake system (abs) loses battery and/or ignition power to the controller, the dash warning light for the abs may not illuminate to warn the driver of the loss of abs. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 121, air brake systems, and 136, electronic stability control system on heavy vehicles.
Consequence
If the driver unknowingly operates the vehicle without the abs functioning, there would be an increased risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will update the namux software within the cab control module, free of charge. Paccar issued owners an interim notification on june 4, 2020. The recall began may 26, 2020. Owners may contact kenworth customer service at 1-425-828-5888 or peterbilt customer service at 1-940-591-4220. Paccar's number for this recall is 20pbc and 20kwb.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #11 - ELECTRONIC STABILITY CONTROL
Posted on: 2020-04-07
Description
Paccar incorporated (paccar) is recalling certain 2008-2019 peterbilt 330, 335, 337, 340, 348, 365, 367, 384, 386, 387, 388, 389, 567, 579 and 587 vehicles and 2008-2020 kenworth t170, t270, t370, t660, t680, t800, t880, and w900 vehicles equipped with namux software. In the event that the anti-lock brake system (abs) loses battery and/or ignition power to the controller, the dash warning light for the abs may not illuminate to warn the driver of the loss of abs. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 121, air brake systems, and 136, electronic stability control system on heavy vehicles.
Consequence
If the driver unknowingly operates the vehicle without the abs functioning, there would be an increased risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will update the namux software within the cab control module, free of charge. Paccar issued owners an interim notification on june 4, 2020. The recall began may 26, 2020. Owners may contact kenworth customer service at 1-425-828-5888 or peterbilt customer service at 1-940-591-4220. Paccar's number for this recall is 20pbc and 20kwb.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.