5 recalls found. |
DEFECT #1 - SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
Posted on: 1990-10-26
Description
The suspension coil spring box mounting brackets, which are fastened to the main chassis frame, may fail.
Consequence
Bracket failure allows the coil spring box to move and,consequently, damage the rear brake lines affecting brake performance.
Corrective Action
Repair to prevent mounting bracket failure.
Notes
System: suspension coil mounting brackets.vehicle description: 36 and 37 foot class a motorhomes built on a gilligchassis with mor-ryde suspension.
DEFECT #2 - SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 1987-08-18
Description
Routing of air supply lines close to the exhaust manifold pipe subject the lines to deformation and possible rupture from the radiant heat of the pipe.
Consequence
Rupture of air pressure lines could cause low airpressure and park brake warning lights to come on; it will automatically applypark/emergency brake and deflate front suspension air bags.
Corrective Action
Replace damaged air lines and install a protective heat shield or reposition air lines away from exhaust pipe.
Notes
System: air supply lines.vehicle description: 36 ft. Class a motorhomes.
DEFECT #3 - EQUIPMENT:RECREATIONAL VEHICLE:LPG LINES AND FITTINGS
Posted on: 1988-10-11
Description
Leak in lp gas service line caused by line contacting rear suspension system which results in line rupture.
Consequence
A ruptured line would release lp gas to the atmospherecreating the possibility of an explosion and/or fire and potential personalinjury to any occupant or person in close proximity of the motorhome.
Corrective Action
The lp gas service line will be relocated to preclude contact with the rear suspension system.
Notes
System: fuel/lp gas.vehicle description: motorhomes model aluma lite and monitor class a equippedwith mor/ryde suspension system.
DEFECT #4 - ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
Posted on: 1987-06-12
Description
Wiring harnesses located to the rear of the engine compartment could chafe and short circuit.
Consequence
This could result in an engine compartment fire.
Corrective Action
Install protective insulated tape.
Notes
System: engine/wiring harnesses.vehicle description: class a motorhomes built on chevrolet chassis or gilligchassis equipped with ford drivetrain.
DEFECT #5 - ELECTRICAL SYSTEM:BATTERY:CABLES
Posted on: 1988-01-28
Description
Under heavy demand on the engine and transmission, the transmission cooler line temperature can exceed the temperature rating of both the plastic conduit and insulation for the battery cable.
Consequence
A direct short could occur between the unprotectedbattery cable wire and metal transmission cooler line creating the possibilityof an engine compartment fire.
Corrective Action
Remove the battery cable from the transmission line and refasten it to another secure location.
Notes
System: battery cablevehicle description: class a motorhomes built on chevrolet p 30 chassis.