5 recalls found. |
DEFECT #1 - STRUCTURE:FRAME AND MEMBERS
Posted on: 1998-12-18
Description
Vehicle description: passenger vehicles originally sold or currently registered in connecticut, delaware, district of columbia, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, nebraska, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, virginia, west virgnia, and wisconsin. The rear lower subframe mount plate nut can experience stress corrosion cracking if subjected to long term exposure to road salts. This can result in fracture and loss of the structural integrity of the subframe mount attachment. Detachment of the body mounts at the rear corners of the subframe, which supports the engine and transmission, allows the rear corners of the subframe to drop.
Consequence
If both rear corners drop, steering would become suddenly very difficult, affecting vehicle control and increasing the risk of a crash.
Corrective Action
Dealers will install subframe rear mount bolts, reinforcement plates, and plate nuts.
Notes
Note:this recall campaign supercedes recall campaign 93v-106.owner notification is expected to begin january 18, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - VEHICLE SPEED CONTROL
Posted on: 1997-03-03
Description
Vehicle description: vehicles equipped with 3.8l engines and originally sold or currently registered in the following states: alaska, colorado, iowa, idaho, illinois, indiana, kansas, massachusetts, maine, michigan, minnesota, missouri, montana, north dakota, nebraska, new hampshire, new york, ohio, pennsylvania, south dakota, vermont, wisconsin, and wyoming. Water can accumulate within the speed control cable conduit. If enough water accumulates, it could freeze within a low area of the cable routing when exposed to a long term cold soak at temperatures at least several degrees below freezing.
Consequence
Driver control of vehicle speed using the speed control system or the accelerator control system would be diminished increasing the risk of a vehicle crash.
Corrective Action
Dealers will add a boot to the speed control cable.
Notes
Owner notification:owner notification is expected to begin april 7, 1997.note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contract the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #3 - WHEELS
Posted on: 1992-05-20
Description
Children can accidentally lock themselves in the footwell area of the rear-facing third seat, or in the storage compartment in station wagons not equipped with an optional third seat. Once the compartment is closed it cannot be opened from the inside.
Consequence
There is a danger of air deprivation, hyperthermia,and/or panic response to a child who has locked himself or herself into thecompartment, with the possibility of asphyxiation.
Corrective Action
Replace the self-latching assembly currently used in the rear storage compartment with a latch assembly that can only be closed with a key.
Notes
System: structure: storage compartments.vehicle description: passenger cars (station wagons).note: ford will have sufficient quantities of the new latch assemblies availableto begin the replacement recall in july, 1992. Until the latch assembly isreplaced, ford recommends owners lock the storage compartment when not in use.also, ford advises that the latch striker can be removed to disable the currentlatch until revised latch assemblies are available.
DEFECT #4 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
Posted on: 1991-08-07
Description
Front disc brake rotors of the subject vehicles may experience severe corrosion if operated in areas where calcium chloride and sodium chloride are used extensively.
Consequence
Severely corroded rotors may fracture or separate nearthe inner edges of the brake discs resulting in reduced braking effectiveness,higher than normal pedal efforts, loud grinding noises, and moderate pulls whenthe brakes are applied. Reduced braking effectiveness may increase minimumstopping distances, possibly resulting in an accident.
Corrective Action
Replace front brake rotors with full cast front brake rotors.
Notes
System: brakes.vehicle description: passenger vehicles sold or registered in the following states: ct, il, in, me, ma, mi, nh, nj, ny, oh, pa, ri, vt, and wi.
DEFECT #5 - SUSPENSION:FRONT:SHOCK ABSORBER
Posted on: 1994-12-01
Description
The arc welds on the sway bar bracket, where it attaches to the strut reserve tube, did not fuse properly.
Consequence
Over time, a portion of the bracket can tear away from the strut, falling into and puncturing the tire or causing damage to the wheel, which could result in an accident.
Corrective Action
Monroe dealers will replace the strut free of charge.
Notes
Equipment description: aftermarket shock absorbers for 1986 - 1994 ford taurus and mercury sable passenger cars; part 71780, 81780.if the vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time or the remedy does not correct the defect, please contact monroe at 1-800-521-6754. Also, contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.