4 recalls found. |
DEFECT #1 - STRUCTURE:BODY
Posted on: 1996-04-22
Description
The fasteners used to secure the mounting foot of either forward or rearward handrails could be installed in such a manner as to allow the possibility that the nut used in nhtsa's handrail inspection procedure will catch between the fasteners.
Consequence
A passenger's clothing could become caught in the handrail, and if the bus driver closes the door and puts the vehicle in motion, the individual is subject to being dragged by the bus. This can result inserious injury or death.
Corrective Action
Replace or reposition the handrails to stop clothing from becoming caught.
Notes
System: equipment; other pieces; handrail at bus entry ways. Vehicle description: school buses. Note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact thomas built at 1-910-889-4871. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #2 - LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Posted on: 1994-11-22
Description
The hole in the bolt portion of the vandalock was drilled in an incorrect location, allowing the pin to be inserted with the bolt in the locked position while bypassing the starter interlock. This can result in the engine starting system operating while the emergency exit door is locked. This does not meet the requirements of fmvss no. 217, bus window release and retention.
Consequence
Consequence of non-compliance: vehicles operated while emergency exits are locked result in increased risk of passenger entrapment when involved in an accident.
Corrective Action
Dealers will rivet a metal shield to the vandalock cover to prevent pin insertion in the event that the pin hole has been incorrectly located.
Notes
System: structure; door assembly; latches and locks.vehicle description: school buses equipped with vandalock systems at the emergency exit doors.note: if the vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time or the remedy does not correct the noncompliance, please contact thomas built at 1-910-889-4871. Also, contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #3 - ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
Posted on: 1994-06-29
Description
A cable installed to temporarily bypass the neutral switch to enable the engine to be started was not removed at delivery. The cable allows the bus to be started while in a forward or reverse drive gear.
Consequence
Consequence of defect: starting a bus in a drive gear can result in unintentional movement and could result in an accident.
Corrective Action
Dealers will remove the temporary cable and install a new relay.
Notes
System: electrical system; alternator; regulator; starter.vehicle description: transit and school buses built on a navistar chassis witht444e engines.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided within a reasonable time and free of charge or the remedy does not correct the defect or noncompliance, please contact thomas built service center at 1-910-889-4871. Also, contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #4 - STRUCTURE:BODY
Posted on: 1996-05-09
Description
The door hinges were not shielded and can snag exiting children's clothing or accessories.
Consequence
When a passenger's clothing becomes caught in the handrail, and the bus driver closes the door and puts the vehicle in motion, the individual is subject to being dragged by the bus. This can result in serious injury or death.
Corrective Action
Dealers will install hinge pads to prevent the snagging of passenger's clothing.
Notes
System: equipment; handrails at bus entryways. Vehicle description: school buses equipped with jack-knife service doors and not equipped with hinge protector pad. Note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact thomas built at 1-910-889-4871. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.