Recalls for 1995 Spartan Ic Chassis

DEFECT #1 - ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Posted on: 1995-03-31
Description
When in operation, the pre-heater requires good engine ground.  However, the alternators are not grounded through the case, limiting the ground for engine electrical components.  The pre-heater amperage can then ground to the steel braided air compressor hose which is secured in a rubber lined clip.  In some circumstances, the clip can contact the frame rail causing an arc.

Consequence
This condition can cause a hole to be burned through the air line, preventing the air compressor from delivering sufficient air pressure to the braking system reducing brake capability and increasing the potential for a vehicle accident.

Corrective Action
Dealers will install a 6 gauge ground cable between the engine and the existing starter ground cable located inside the frame rail.

Notes
System: electrical; alternator; regulator; starter.vehicle description: motorhome chassis equipped with a 1994 or later 300 h.p.c 8.3 cummins engine equipped with pre-heaters and a 160 amp leece neville powerline alternator.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, please contact spartan at 1-517-543-6400, ext.  370.also contact the national highway traffic safety administration's auto safety hotline at1-800-424-9393.