8 recalls found. |
DEFECT #1 - FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Posted on: 1998-03-27
Description
Vehicle description: passenger vehicles previously serviced under ford service bulletin 97-17-9 from august 1997 through december 1997. These vehicles were inadvertenly equipped with an 18-gallon fuel tank rather than the 16-gallon as specified. The 18-gallon tank has a second valve location where a shipping plug should be installed.
Consequence
If this shipping plug is displaced, fuel leakage can result. Fuel leakage in the presence of an ignition source could potentially result in a fire.
Corrective Action
Dealers will install the correct fuel tank.
Notes
Owner notification began june 17, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Posted on: 1996-09-23
Description
The park pawl abutment bracket has a sharp edge which can cause the parking pawl to hang up and not engage the park gear. This would allow the vehicle to move even though the gear shift indicator shows that the vehicle is in park.
Consequence
Unintended and unexpected vehicle movement can result in personal injury and property damage.
Corrective Action
Dealers will inspect and, if necessary, replace the park pawl abutment bracket.
Notes
Owner notification:owner notification is expected to begin september 23, 1996.note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #3 - FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
Posted on: 1996-08-27
Description
The fuel pressure regulator located on the fuel rail in the engine compartment has a vacuum diaphragm that was damaged during manufacture of the regulator.
Consequence
If the diaphragm tears or ruptures, liquid fuel could enter the intake manifold plenum through the vacuum line resulting in either release of fuel from the air cleaner assembly or the exhaust system. Fuel release in the presence of an ignition source could potentially result in a fire.
Corrective Action
Dealers will inspect the fuel pressure regulator. Those regulators produced during the suspect time period will be replaced.
Notes
Owner notification:owner notification is expected to begin september 9, 1996. Note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #4 - SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE WARNING
Posted on: 1996-01-30
Description
The brake system fluid level indicator lamp switch can malfunction. This does not comply with fmvss no. 105, hydraulic brake systems.
Consequence
Consequence of non-compliance: if the switch malfuntions, the brake system warning lamp will either remain illuminated continuously or fail to light as intended when the fluid level falls to a certain level. In either case, the vehicle operator would not be warned of a low brake fluid level condition.
Corrective Action
Dealers will replace the brake system fluid level indicator lamp switches.
Notes
System: brakes; hydraulic; switch; brake warning; fmvss no. 105.vehicle description: passenger vehicles. Note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact ford at 1-800-392-3673. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #5 - POWER TRAIN:AUTOMATIC TRANSMISSION
Posted on: 1996-09-26
Description
The automatic transmission park pawl shaft may not be free to rotate as intended. If the park pawl shaft does not rotate, it would prevent the park pawl from engaging the park gear when the shift lever is in the park position.
Consequence
This condition could result in the vehicle rolling as if in neutral with the shift lever in the park position.
Corrective Action
Dealers will inspect the park pawl shaft rotation and those shafts with restricted rotation will be replaced with a shorter shaft that will not restrict rotation.
Notes
Owner notification:owner notification is expected to being september 30, 1996. Note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #6 - POWER TRAIN:AUTOMATIC TRANSMISSION
Posted on: 1996-05-17
Description
The park pawl shaft was improperly positioned when the roll pin that retains it was installed during transmission assembly. If the shaft was not properly positioned, the roll pin may not have lined up with the groove in the shaft and have been crushed at assembly. Also, a burr could have been raised on the shaft.
Consequence
This could result in the park pawl occasionally not engaging when the transmission selector lever is placed in the park position. This could result in the vehicle rolling as if in neutral if the vehicle operator does not apply the parking brake.
Corrective Action
Dealers will inspect the park pawl shaft roll pin. If the roll pin is damaged, both the roll pin and the park pawl shaft will be replaced. In addition, owners will be reminded to fully apply the parking brake, in addition to placing the transmission in park.
Notes
System: power train; transmission; automatic. Vehicle description: passenger vehicles and mini-vans equipped with ford ax4s automatic transaxles. Note: owner notification is expected to begin in mid-june 1996. Note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact ford at 1-800-392-3673. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #7 - EXTERIOR LIGHTING
Posted on: 2006-03-23
Description
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Corrective Action
Pro-a motors will notify owners and offer to repurchase the lamps. The recall began on april 3, 2006. Owners may contact pro-a motors at 323-838-2988.
Notes
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled lamp model numbers.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #8 - EXTERIOR LIGHTING
Posted on: 2009-04-07
Description
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. These lamps do not contain the required amber side reflectors.
Consequence
Decreased lighting visibility may result in a vehicle crash.
Corrective Action
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.
Notes
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under document search located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .