|
|
Recalls for
1997 Chevrolet S10
|
8 recalls found.
|
DEFECT #1 - ELECTRICAL SYSTEM:BATTERY
Posted on: 2001-01-17
Description
Vehicle description: generation 1 electric light duty pickup trucks. These vehicles were built with a charge port assembly that could fail during a charging event.
Consequence
Heat could build up within the charge port and a fire could result.
Corrective Action
Dealers will replace the charge port assembly with a redesigned charge port assembly.
Notes
Owner notification began march 23, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). DEFECT #2 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 2000-06-16
Description
Vehicle description: electric pickup trucks. A condition in which the fuel-fired heater fill pipe ground strap contacts the rear passenger side brake pipe.
Consequence
This could wear off the corrosion protection on the brake pipe, leading to premature corrosion and eventual loss of brake pipe integrity. When brake pipe integrity is lost, brake fluid leakage can occur.
Corrective Action
Dealers will relocate the ground strap attachment, inspect the brake pipe for wear, and replace the brake pipe if necessary.
Notes
Owner notification began july 28, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). DEFECT #3 - VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
Posted on: 1998-08-14
Description
Vehicle description: light duty pickup trucks equipped with electric drive. Rapid fogging of the interior glass can occur within two minutes after the heat is turned on if (1) the outside temperature is between 35 and 76 degrees fahrenheit and (2) water has collected on the heat exchanger during previous operation of the air conditioning.
Consequence
If rapid fogging were to occur during driving, it could obstruct the driver's vision increasing the risk of a vehicle crash.
Corrective Action
Owners are being provided with a caution label and supplemental insert for their owner's manual advising them to follow a stop and wait procedure to help avoid window fogging while driving.
Notes
Owner notification began during august 1998.owners who do not receive the caution label within a reasonable time should contact chevrolet at 1-800-222-1020.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). DEFECT #4 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 1997-09-16
Description
Vehicle description: light duty passenger pickup trucks equipped with 4.3l engines. The front brake line can contact the left-hand side of the engine oil pan causing the brake line to wear to the point of brake fluid loss during brake application.
Consequence
Brake fluid loss can reduce braking effectiveness and increase stopping distances resulting in a vehicle crash without prior warning.
Corrective Action
Dealers will inspect the clearance between the oil pan and the brake line. If the clearance is 6mm or less, dealers will install an additional brake line clip and if there was contact between the oil pan and brake line, the front brake line will be replaced.
Notes
Owner notification is expected to begin during october 1997.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. DEFECT #5 - SEAT BELTS
Posted on: 1997-08-21
Description
Vehicle description: extended cab pickup trucks equipped with 60/40 front bench seats and extended cab pickup trucks and 2-door utility vehicles equipped with manual locking recliner bucket seats. The outboard safety belt webbing on the driver's and/or passenger's seat can separate during a frontal impact.
Consequence
If a separation occurred and there were secondary crash events or vehicle rollover, there would be no belt restraint of the occupant and increased injuries could occur.
Corrective Action
Dealers will install a protective cover over the recliner mechanism.
Notes
Owner notification:owner notification will begin during september 1997. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. DEFECT #6 - VISIBILITY:WINDSHIELD WIPER/WASHER
Posted on: 2003-04-30
Description
On certain minivans, pickup trucks, and sport utility vehicles with certain model-engine combinations, the windshield wiper motor may fail due to cracked solder joints on the controller circuit board. The windshield wipers could work intermittently or not at all.
Consequence
If this were to occur during bad weather, driver visibility would be reduced, which could result in a crash.
Corrective Action
Dealers will replace the wiper motor circuit board and cover. Owner notification began on june 19, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, gmc at 1-800-462-8782, or oldsmobile at 1-800-442-6537.
Notes
Gm recall no. 03023.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). DEFECT #7 - FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
Posted on: 2007-03-12
Description
Certain delphi fuel pressure regulators, p/nos. Fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. The universal pressure regulators (upr) were produced without an o'ring and retainer.
Consequence
Fuel may leak, possibly resulting in a fire.
Corrective Action
Delphi will notify owners and replace the upr free of charge. The recall began on april 23, 2007. Owners can contact delphi at 877-411-8770.
Notes
This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. DEFECT #8 - EXTERIOR LIGHTING:HEADLIGHTS
Posted on: 2009-05-11DescriptionDope, inc. Is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. These lamps do not contain the required amber side reflectors.
ConsequenceDecreased lighting visibility may result in a vehicle crash.
Corrective ActionDope, inc. Will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on july 28, 2009. Owners may contact dope, inc. At 1-626-272-1798.
NotesThis recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under document search located at the bottom of your screen. Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to
http://www.safercar.gov .