5 recalls found. |
DEFECT #1 - STRUCTURE
Posted on: 2001-08-02
Description
Vehicle description: travel and fifth wheel trailers. The fasteners used on the underfloor can either come loose or pull through the underfloor causing portions or all of a section of underfloor to detach from the vehicle.
Consequence
If this occurred, the section could fall to the pavement, potentially causing a crash for following vehicles.
Corrective Action
Dealers will add or replace fasteners. Owner notification began september 28, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jayco at 1-219-825-5861.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS
Posted on: 1998-06-03
Description
Vehicle description: mini-motor homes, travel trailers, and fifth wheels equipped with a printed circuit (pc) board housed in the electrical control box assembly equipped with the vehicle's air conditioning unit. An electrical relay on the pc board will fail to activate. When the relay fails to activate, other electrical components, and the pc board itself, are required to carry excess electrical current.
Consequence
The electrical components and the pc board can overheat, char and produce smoke, possibly resulting in a fire.
Corrective Action
Rv products is conducting the owner notification and remedy campaign for this recall. Owners will receive a replacement electrical control box and installation instructions. If an owner so desires, they can have their dealer install this control box.
Notes
Owner notification began during december 1997. Owners who do not receive a free replacement electrical control box within a reasonable time should contact r. V. Products at 1-800-227-5693 or jayco at 1-219-296-6000. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS
Posted on: 1997-05-01
Description
An in-line fuse to the auxiliary battery was omitted.
Consequence
If a short occurred in the power line from the battery without the presence of over-current protection, the 12 volt line can overheat, increasing the risk of a fire.
Corrective Action
Dealers will install an in-line fuse to the auxiliary battery.
Notes
Note:owner notification began march 21, 1997, with followup letters beging mailed during july 1997.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jayco at 1-219-825-0670.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #4 - STRUCTURE
Posted on: 1997-07-30
Description
Vehicle description: fifth wheel and travel trailers. Rivets used to secure the step risers on these vehicles are the wrong size. The rivets are too short in length and under stress can allow the step treads to become unattached from the mounting bracket.
Consequence
If the step riser falls from the mounting bracket while a person is stepping on it, personal injury could occur.
Corrective Action
Dealers will replace the step riser assembly.
Notes
Notes:owner notification will begin during july 1997.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jayco at 1-219-825-0670.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #5 - VEHICLE SPEED CONTROL
Posted on: 2006-08-30
Description
On certain motor homes built on ford chassis, the speed control deactivation switch may overheat.
Consequence
Overheating could result in smoke or burning, and in an underhood fire.
Corrective Action
Ford is conducting this recall (please see 06v286) and will install a fused wiring harness into the speed control system free of charge. Owners may contact ford at 1-866-436-7332 or jayco at 1-800-283-8267.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.