7 recalls found. |
DEFECT #1 - EQUIPMENT:RECREATIONAL VEHICLE
Posted on: 2000-02-09
Description
Vehicle description: fold down trailers which use gas/electric absorption refrigerators supplied by norcold. The swivel nut which is an integral connection component of a pressure tap device has stress corrosion cracking.
Consequence
This cracking can lead to an open fracture in the brass nut, potentially allowing propane gas to leak.
Corrective Action
Dealers will remove the swivel nut/pressure tap component and replace with a remedy kit.
Notes
Jayco recall no. 9901029.owner notification began december 30, 1999. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jayco at 1-877-825-4872 or norcold at 1-937-497-3080.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS
Posted on: 1998-06-03
Description
Vehicle description: mini-motor homes, travel trailers, and fifth wheels equipped with a printed circuit (pc) board housed in the electrical control box assembly equipped with the vehicle's air conditioning unit. An electrical relay on the pc board will fail to activate. When the relay fails to activate, other electrical components, and the pc board itself, are required to carry excess electrical current.
Consequence
The electrical components and the pc board can overheat, char and produce smoke, possibly resulting in a fire.
Corrective Action
Rv products is conducting the owner notification and remedy campaign for this recall. Owners will receive a replacement electrical control box and installation instructions. If an owner so desires, they can have their dealer install this control box.
Notes
Owner notification began during december 1997. Owners who do not receive a free replacement electrical control box within a reasonable time should contact r. V. Products at 1-800-227-5693 or jayco at 1-219-296-6000. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS
Posted on: 1997-05-01
Description
An in-line fuse to the auxiliary battery was omitted.
Consequence
If a short occurred in the power line from the battery without the presence of over-current protection, the 12 volt line can overheat, increasing the risk of a fire.
Corrective Action
Dealers will install an in-line fuse to the auxiliary battery.
Notes
Note:owner notification began march 21, 1997, with followup letters beging mailed during july 1997.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jayco at 1-219-825-0670.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #4 - SUSPENSION:REAR
Posted on: 1998-01-05
Description
Vehicle description: travel and folding trailers equipped with dexter axles. The wheel bearings used in some of these axles have a metallurgical defect causing early failure.
Consequence
A wheel bearing failure could result in the loss of the wheel end from the axle increasing the risk of a vehicle crash.
Corrective Action
Dexter axle is conducting the notification and remedy for this recall. Dealers will inspect the axles and replace the wheel bearings if necessary.
Notes
Owner notification began during november 1997. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact dexter axle at 1-800-400-2164.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #5 - FUEL SYSTEM, OTHER:STORAGE
Posted on: 1998-06-02
Description
Vehicle description: travel trailers equipped with 20 lb. Lpg cylinders supplied by manchester tank. These cylinders are equipped with an overfill protection. The overfill protection device may not function properly.
Consequence
If a cylinder is overfilled, and some of the gas leaks out, the vapors could ignite if there was a source of ignition present.
Corrective Action
Manchester tank is performing the owner notification and remedy campaign for this recall. Manchester will replace these lpg cylinders.
Notes
Owner notification by manchester tank began january 28, 1998.owners who do not get their lpg cylinder replaced free of charge within a reasonable time should contact manchester tank/recall management at 1-800-420-7511.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #6 - STRUCTURE
Posted on: 1997-07-30
Description
Vehicle description: fifth wheel and travel trailers. Rivets used to secure the step risers on these vehicles are the wrong size. The rivets are too short in length and under stress can allow the step treads to become unattached from the mounting bracket.
Consequence
If the step riser falls from the mounting bracket while a person is stepping on it, personal injury could occur.
Corrective Action
Dealers will replace the step riser assembly.
Notes
Notes:owner notification will begin during july 1997.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jayco at 1-219-825-0670.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #7 - VEHICLE SPEED CONTROL
Posted on: 2006-08-30
Description
On certain motor homes built on ford chassis, the speed control deactivation switch may overheat.
Consequence
Overheating could result in smoke or burning, and in an underhood fire.
Corrective Action
Ford is conducting this recall (please see 06v286) and will install a fused wiring harness into the speed control system free of charge. Owners may contact ford at 1-866-436-7332 or jayco at 1-800-283-8267.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.