4 recalls found. |
DEFECT #1 - STEERING
Posted on: 2007-06-26
Description
On certain transit buses, the u-joint assemblies have inadequate spline engagement on one of the two end yokes.
Consequence
Excessive play in the steering system could develop and, if not corrected, cause a loss of steering control which could result in a crash.
Corrective Action
The u-joint assembly will be inspected and replaced if necessary. The recall began on june 10, 2007. Owners may contact new flyer at 1-204-934-4874.
Notes
Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #2 - EXTERIOR LIGHTING
Posted on: 2007-02-27
Description
Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 108, lamps reflective devices, and associated equipment. The flashing deceleration lamps were an optional item for some of these buses.
Consequence
The standard requires that the deceleration lamp is a solid light rather than a flashing light.
Corrective Action
Dealers will rewire the electrical system to remove the flashing function or install a new programmable logic controller (plc) which will make the lamps burn steady free of charge. The recall began on march 5, 2007. Owners may contact new flyer at 204-934-4874.
Notes
Customers may contact the national highway traffic safety administration1s vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #3 - WHEELS
Posted on: 2004-02-10
Description
On certain transit buses, the center axle wheel end brakes may not release after being parked for an extended period of time.
Consequence
The driver could lose control of the vehicle when driving away from a parked position, which could result in a crash.
Corrective Action
New flyer will install an additional air system r14 relay valve, #4 notch automatic slack adjusters, and type 30 long stoke brake chambers on the center axle; the logic control module will be reprogrammed, add new abs components (sensors, speed rings and harnesses) if not already equipped with abs; and will revise plc programming. Owners may contact new flyer at 1-204-982-8400.
Notes
Customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - EQUIPMENT:AIR CONDITIONER
Posted on: 2008-02-05
Description
New flyer is recalling 431 my 1996-2001 d60hf diesel transit buses equipped with a rooftop air conditioning evaporator. The evaporator drain lines make contact with components (ballast assemblies) within the interior lighting panel below the drain line port. This can result in either damage to the drain line, which introduces moisture into the lighting panel, or restriction of the line which results in a back-up and overflow of moisture through the fresh air return vent and back into the lighting panel.
Consequence
Moisture in sufficient quantities within the lighting panel may result in a shorting of the electrical components and a vehicle fire.
Corrective Action
New flyer will incorporate an elbow fitting into the drain line where it enters the lighting panel from the roof, which will promote clearance between the line and the ballast assembly. The recall began on february 6, 2008. Owners may contact new flyer at 1-204-934-4803.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.