Recalls for your 1998 Nabi 40lfw

Recalls for 1998 Nabi 40lfw

RSS Feed


4 recalls found.
All Nabi Recalls
Beautiful sky

Capital Rails and Transit posted a photo:

Beautiful sky

One of my first experiment photos tested with my new camera at Virginia Square with one of these Nabis, Pretty cool looking units.
Alrington Transit 2015 Nabi 40 LFW 5092 on Route 75 at Virginia Square Station.

Taken: November 1, 2022

DEFECT #1 - STEERING:HYDRAULIC POWER ASSIST SYSTEM


Posted on: 2005-03-14
Description
On certain transit buses, the front axle stops and the power steering gear hydraulic limit valves were found to be out of adjustment.  The drag link may experience permanent deformation due to the steering load.

Consequence
During long term operation involving repeated flexing of the drag link, it may eventually crack and break.  The driver will no longer have steering control of the vehicle and a crash could occur causing injury or death.  

Corrective Action
Dealers will inspect and replace the drag links with a stronger drag link.  Dealers will also inspect the steering gear hydraulic limit valve settings.  The recall began on may 16, 2005.  Owners may contact nabi at 256-831-4296.

Notes
Nabi recall no.  20052.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

DEFECT #2 - ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO-CHARGER


Posted on: 2004-10-12
Description
On certain transit buses equipped with detroit diesel series 50 engines, the turbocharger can fail allowing lubricating oil to enter the exhaust system.  

Consequence
In the event the turbocharger fails, a fire may occur in the engine compartment resulting in property damage or injuries.  

Corrective Action
Detroit diesel is conducting the owner notification and remedy for this campaign.  Dealers will repair the engine and install an exhaust temperature sensor to prevent the possibility of an exhaust or engine compartment fire.  Owners should contact detroit diesel corporation at 313-592-5791 or nabi at 1-256-831-4296.  

Notes
Nabi recall no.20044.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

DEFECT #3 - VEHICLE SPEED CONTROL


Posted on: 2003-10-09
Description
On certain transit buses equipped with cummins electronic control modules on the l10g engines, the ecm does not have the ability to detect a throttle fail-safe engine shutdown command.  This could result in an unanticipated, uncommanded open throttle condition without warning.  

Consequence
If this event occurs, the vehicle operator will not have control of the engine speed, possibly resulting in a vehicle crash.

Corrective Action
Cummins will notify the customers and replace the ecm.  Owners should contact cummins at 1-800-343-7357 or nabi at 256-832-4296.

Notes
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

DEFECT #4 - SUSPENSION:REAR


Posted on: 2002-12-20
Description
On certain transit buses equipped with diesel or liquid natural gas (lng) fuel systems only, in the area of the rear axle lower radius rod attachment to the suspension support (or c frame), a welding problem exists.  

Consequence
If a crack were to develop and propagate around the circumference of the bushing, the radius rod attachment could become loose and allow movement between the lower radius rod and the rear axle.  Should this happen, the rear axle position could shift during acceleration, deceleration, or in turns, and could affect the handling of the vehicle.  

Corrective Action
Owners are being requested to inspect their buses for cracks and to remove the buses from service that have cracks exceeding specific criteria.  Nabi will arrange to repair all the vehicles.  Owner notification is expected to begin on december 31, 2002.  Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact nabi at 1-888-424-5844, extension 7900.

Notes
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).