Recalls for your 1999 Blue Bird Commercial Series

Recalls for 1999 Blue Bird Commercial Series

RSS Feed


11 recalls found.
All Blue Bird Recalls

DEFECT #1 - SUSPENSION


Posted on: 2001-11-05
Description
Vehicle description: school buses equipped with hendrickson rear air suspension.  Inadequate tightening of the 5/8 bolts on the rear air suspension hanger bolts and on rear axle torque arm axle seat studs.

Consequence
Insufficient tightening permits movement between the components that could result in bolts and studs breaking, increasing the risk of a crash.

Corrective Action
Dealers will replace the 5/8 grade 8-hanger bolts.  In addition, axle spring seat fasteners will be checked for proper tightness and, if needed, tightened to specifications.  Owner notification began january 18, 2002.  Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-478-822-2242.

Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

DEFECT #2 - ELECTRICAL SYSTEM:WIRING


Posted on: 2001-06-14
Description
Vehicle description: school and transit buses equipped with rear mounted engines.  The 12-volt power supply cable(s) may be chaffed by hoses, harnesses, frame components, or clamps.

Consequence
This condition can result in power failure and/or risk of fire in the engine compartment.

Corrective Action
Dealers will remove and inspect the 12-volt power cable(s) from the battery to the starter and, if necessary, will replace the cables.  Owner notification began july 30, 2001.  Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-912-822-2242.

Notes
Blue bird recall no.  R01ff.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

DEFECT #3 - STEERING:LINKAGES:TIE ROD ASSEMBLY


Posted on: 2001-02-28
Description
Vehicle description: school and transit buses and motor home chassis equipped with tie rod assemblies manufactured by trw.  The suspect tie rods contain 24-dl model ball sockets.  Certain of the tie rod ball-socket bearings have a below-specification case depth and/or hardness, which can lead to premature wear of the socket.

Consequence
If this condition occurs, the driver can lose partial control of the right front wheel, possibly resulting in a crash.

Corrective Action
Dealers will replace the defective ball sockets and/or drag links.  Owner notification began march 30, 2001.  Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-912-822-2242 or trw customer service at 1-866-280-3287.

Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

DEFECT #4 - VEHICLE SPEED CONTROL:ACCELERATOR PEDAL


Posted on: 2000-08-23
Description
Vehicle description: school and transit buses equipped with electronic engines and felsted electronic accelerator pedals.  The return springs can break on the accelerator pedals that are equipped with stainless steel or electroplated music wire return springs.

Consequence
This condition could cause the pedal to go to full throttle if both return springs break, increasing the risk of a crash.

Corrective Action
Replacement accelerator pedals equipped with return springs manufactured of music wire with one additional coil on each spring and with an organic coating, eliminating electroplating will be installed.

Notes
Owner notification began august 18, 2000.  Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-912-822-2242.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

DEFECT #5 - SERVICE BRAKES, AIR:ANTILOCK


Posted on: 2001-01-26
Description
Vehicle description: transit and school buses equipped with meritor wabco phase 1, d-version antilock brake system (abs), fail to comply to the requirements of fmvss no.  105, hydraulic and electric brake systems.  An internal diagnostic system in the abs may not detect an extreme wheel speed sensor air gap.  Such a condition could possibly occur during (1) original assembly or (2) subsequent wheel end service.

Consequence
Failure of the electronic control unit to detect an extreme wheel speed sensor air gap can result in the loss of antilock braking function on the wheel(s) where the air gap exists, increasing the risk of a crash.

Corrective Action
The abs ecu will be removed and replaced or the ecu will be reprogrammed.

Notes
Owner notification began february 12, 2001.  Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at.  Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

DEFECT #6 - SERVICE BRAKES, AIR:CONTROLS:FOOT CONTROL


Posted on: 2000-06-16
Description
Vehicle description: school and transit buses equipped with bendix air brakes.  Bendix changed the internal design of the qr1c relay valve by adding a hole in the internal diaphragm.  When the hole in the diaphragm aligns with the hole in the valve body, the brake application time increases.

Consequence
Under certain conditions, such as parked on an incline, driver activates the parking brake but removes foot from the threadle valve, the bus could roll before the parking brake is fully engaged.

Corrective Action
Dealers will replace the diaphragms with holes with solid diaphragms for the qr1c valves.

Notes
Owner notification began june 14, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-912-825-2021.  Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

DEFECT #7 - VISIBILITY:WINDSHIELD


Posted on: 2000-05-05
Description
Vehicle description: school buses equipped with transit sliding pushout windows.  Potential sticking and/or binding of the pushout window inner frame within the outer frame results in opening forces exceeding the requirements of fmvss no.  217, bus window retention and release.

Consequence
Personal injury could occur in the event of a crash.

Corrective Action
Owners will be provided with step-by-step procedures for modifying the transit sliding pushout windows to conform the fmvss 217 requirements.

Notes
Owner notification began may 25, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-912-825-2021.  Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

DEFECT #8 - SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS


Posted on: 2000-02-28
Description
Vehicle description: school and transit buses equipped with bendix abs anti-lock braking system.  The primary and secondary brake treadle valve air lines were installed incorrectly at the bendix r12dc relay valve.

Consequence
With the brake system installed incorrectly, future maintenance might be affected by this inconsistency, causing the brakes to be installed incorrect, increasing the risk of a crash.

Corrective Action
Dealers will correct the air line plumbing at the bendix r12dc relay valve.

Notes
Owner notification began march 8, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-912-825-2021.  Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

DEFECT #9 - EQUIPMENT ADAPTIVE


Posted on: 2004-08-31
Description
Certain blue bird 1999-2005 all american, tc/2000, micro bird, vision, conventional, and commercial series school buses equipped with sure-loc wheelchair securement systems and manufactured between february 17, 1999, and august 13, 2004.  Certain sure-lok wheelchair tie-down securement assemblies p/n 8625-13.  The sprocket teeth of the retractor assembly may be out of alignment causing the load pawl not to fully seat in the sprocket teeth.

Consequence
In the event of a vehicle crash, the wheelchair may not be adequately secured possibly resulting in injuries.

Corrective Action
Blue bird will notify its customers and replace the defective part free of charge.  The recall began september 21, 2004.  Owners who take their buses to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact at blue bird at 478-822-2242.

Notes
Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

DEFECT #10 - FUEL SYSTEM, DIESEL


Posted on: 2005-02-28
Description
Certain 1998 through 2002 blue bird all american, tc2000 school and transit buses, and commercial series buses equipped with cummins isb diesel engines.  The fuel pump could fail to transfer fuel appropriately creating an engine stall condition.

Consequence
Should the engine stall while the vehicle is in use, a possible vehicle crash could occur.

Corrective Action
Customers will be notified by cummins to bring their vehicles to an authorized dealer to have the fuel lift pump replaced free of charge.  For more information, customers may contact cummins at 1-800-diesels.  

Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

DEFECT #11 - ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR


Posted on: 2003-03-19
Description
On certain school and transit buses equipped with cummins isb 6 cylinder engines, the lower alternator support brace or mounting hardware can loosen or break which will allow the alternator to drop onto the engine.  

Consequence
In this event, the electrical wiring harness may be damaged and the possibility of fire may exist.

Corrective Action
Cummins will notify customers and replace the upper and lower alternator support brackets free of charge.  Owners who take their vehicle to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact cummins at 1-800-343-7357 or blue bird at 478-822-2242.  

Notes
Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).