6 recalls found. |
DEFECT #1 - SERVICE BRAKES, AIR:DISC:ROTOR
Posted on: 2000-08-10
Description
Vehicle description: sport utility electric vehicles. The front disc brake rotor, when equipped with steel wheels, can develop stress fractures if the lug nuts are tightened with excessive torque.
Consequence
The disc rotor could break (where it mounts to the wheel), resulting in a loss of braking action on that wheel, increasing the risk of a crash.
Corrective Action
Dealers will replace the disc brake rotors. If the vehicle is equipped with steel wheels, toyota will replace the front disc brake rotors and steel wheels with new disc brake rotors and new aluminum wheels. In addition a caution label that reads, use new genuine toyota aluminum wheels. Will be affixed. Vehicles already equipped with aluminum wheels will only require caution label installation.
Notes
All these vehicles are leased and operated in fleets.owner notification began september 25, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact toyota at 1-800-331-4331. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START SWITCH
Posted on: 2000-08-10
Description
Vehicle description: sport utility electric vehicles. If the subject vehicles are repeatedly parked by placing the shift lever into the p position without applying the parking brake, the parking lock rod, a component of the transmission parking lock system, could break.
Consequence
This condition can render the system inoperative, increasing the risk of a crash.
Corrective Action
Dealers will replace the parking lock rod.
Notes
All these vehicles are leased and operated in fleets.owner notification began september 25, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact toyota at 1-800-331-4331. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT CONTROLLER
Posted on: 1998-11-09
Description
Vehicle description: sport utility vehicles, mini vans and passenger vehicles equipped with a theft deterrent systems (tds) supplied by audiovox corporation and distributed by southeast toyota distributors, inc. In the states of alabama, florida, georgia, north and south carolina. The alarm wiring harness plugs into the vehicle's ignition switch and the vehicle's ignition switch wiring harness plugs into the alarm harness to complete the circuit. A percentage of the female terminals used in the alarm connector were found to be defective, causing an 'open circuit' condition when mated to the male ignition switch terminals.
Consequence
This condition can cause intermittent performance of the vehicle's electrical components such as the dash warning lights and/or hvac fan speed controls. Also, the vehicle may not run smoothly and could stall.
Corrective Action
Dealers will inspect the date code label on the security system harness and any displaying the manufacturing/final date code will be replaced with newly produced harnesses. The date codes are: rav4 - 6/24/98, 6/25/98, 6/26/98; sienna - 6/25/98, 6/26/98; and avalon - 6/30/98, 7/1/98, 8/31/98, 9/1/98, 9/2/98, and 9/3/98.
Notes
Owner notification is expected to begin during october/november 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southeast toyota distributor at 1-800-301-6859.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT CONTROLLER
Posted on: 1998-10-20
Description
Equipment description: aftermarket theft deterrent systems used on 1998-1998 toyota rav4, avalon, and sienna model vehicles distributed by southeast toyota distributors, inc. In the states of alabama, florida, georgia, north and south carolina. The alarm wiring harness plugs into the vehicle's ignition switch and the vehicle's ignition switch wiring harness plugs into the alarm harness to complete the circuit. A percentage of the female terminals used in the alarm connector were found to be defective, causing an open circuit condition when mated to the male ignition switch terminals.
Consequence
This condition can cause intermittent performance of the vehicle's electrical components such as the dash warning lights and/or hvac fan speed controls. Also, the vehicle may not run smoothly and could stall.
Corrective Action
Dealers will inspect the date code label on the security system harness and any displaying the manufacturing/final date code will be replaced with newly produced harnesses. The date codes are: rav4 - 6/24/98, 6/25/98, 6/26/98; sienna - 6/25/98, 6/26/98; and avalon - 6/30/98, 7/1/98, 8/31/98, 9/1/98, 9/2/98, and 9/3/98.
Notes
Owner notification is being handled by southeast toyota distributors.owner notification began november 3, 1998. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southeast toyota distributor at 1-800-301-6859.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #5 - AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Posted on: 2020-01-22
Description
Toyota motor engineering & manufacturing (toyota) is recalling certain 1998-2000 rav4, 1998-1999 rav4 ev and celica and 1997-1998 supra vehicles. These vehicles were equipped with non-azide driver air bag inflators (nadi) and do not contain phase stabilized ammonium nitrate (psan) propellant. Due to a manufacturing issue, the nadi inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence
In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant, and increases the risk of serious injury or death.
Corrective Action
Toyota will notify owners, and owners will have the option to self-inspect, or have a dealer inspect the steering wheel on their vehicle to determine if their vehicle may be equipped with an affected inflator. Potentially affected steering wheel serial numbers will be inspected by a dealer. Based on the inspection, dealers will replace the front driver air bag inflator with an alternate one, as necessary. These repairs will be performed free of charge. The recall began august 28, 2020. Owners may contact toyota customer service at 1-888-270-9371. Toyota's numbers for this recall is 20tb01 and 20ta01.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #6 - AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Posted on: 2020-01-22
Description
Toyota motor engineering & manufacturing (toyota) is recalling certain 1998-2000 rav4, 1998-1999 rav4 ev and celica and 1997-1998 supra vehicles. These vehicles were equipped with non-azide driver air bag inflators (nadi) and do not contain phase stabilized ammonium nitrate (psan) propellant. Due to a manufacturing issue, the nadi inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence
In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant, and increases the risk of serious injury or death.
Corrective Action
Toyota will notify owners, and owners will have the option to self-inspect, or have a dealer inspect the steering wheel on their vehicle to determine if their vehicle may be equipped with an affected inflator. Potentially affected steering wheel serial numbers will be inspected by a dealer. Based on the inspection, dealers will replace the front driver air bag inflator with an alternate one, as necessary. These repairs will be performed free of charge. The recall began august 28, 2020. Owners may contact toyota customer service at 1-888-270-9371. Toyota's numbers for this recall is 20tb01 and 20ta01.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.