5 recalls found. |
DEFECT #1 - EXTERIOR LIGHTING:TAIL LIGHTS:SWITCH
Posted on: 2002-09-16
Description
Certain heavy duty class 8 trucks fail to comply with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. The two tail lamps, back-up lamp,and license tag lamp were mounted on insufficiently rigid mounts.
Consequence
It may not allow the driver of a rearward approaching vehicle to have full view of the lamps.
Corrective Action
Dealers will attach the two tail lamps, back-up lamp, and the license tap lamp on stiffer brackets. Owner notification began october 31, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1-800-528-6586.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - SERVICE BRAKES, AIR:ANTILOCK
Posted on: 2002-04-15
Description
Certain heavy duty class 8 vehicles fail to comply with federal motor vehicle safety standard no. 121, air brake systems, s5.1.6.3, antilock power for towed vehicles. Electrical power for the trailer anti-lock braking system (abs) can be disrupted when a switch located on the vehicle instrument panel is activated to control lighting within the trailer.
Consequence
If this condition occurs, the driver can lose of the towed vehicle, possibly resulting in a vehicle crash.
Corrective Action
Dealers will install a wiring harness which will provide continuous electrical power to the trailer abs whenever the ignition switch is in the on or run position. Owner notification began april 29, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1-800-528-6586.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - EXTERIOR LIGHTING
Posted on: 2002-01-25
Description
Certain heavy duty class 8 trucks fail to comply with the requirements of fmvss no. 108, lamps, reflective devices, and associated equipment. Two reflectors are missing from the end of the frame crossmember.
Consequence
At night, in a bob-tailed (no trailer) condition, the rear of the truck may not be as visible to vehicles following the truck, increasing the risk of a crash.
Corrective Action
Dealers will install the two missing reflectors. Owner notification began december 12, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1-800-528-6586.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - SERVICE BRAKES, AIR:ANTILOCK
Posted on: 2000-08-24
Description
Vehicle description: heavy duty trucks built with bendix air abs with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted abs activation at low speeds caused by 1) chafed abs wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
Consequence
This condition could cause the abs ecu to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.
Corrective Action
Dealers will replace the abs ecu.
Notes
Owner notification was phased.first mailing to critical category a owners began december 11, 2000.all other owner notification began february 12, 2001.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1-800-528-6586.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #5 - SUSPENSION:FRONT
Posted on: 2003-06-03
Description
On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.
Consequence
Seizure of the bearings can cause wheel separation or wheel end fire.
Corrective Action
Dealers will replace all front axle hubs. An interim notice to owners was mailed on june 25, 2003. Final owner notification began on october 6, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo at 1-800-528-6586.
Notes
Volvo recall no. Rvxx0304.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).